Get Electrical System Guide for Citroen Xsara SUV Second Generation (1997-2006)

XSARA PICASSO - All Types

CHECKING AND ADJUSTING THE LOAD-SENSITIVE BRAKE COMPENSATOR

Adjusting the load-sensitive brake compensator

- Untighten the screw (1).

- Move the spring rod.

- Decrease the length of the spring to increase the pressure.

- Increase the length of the spring to decrease the pressure.

- Tighten the screw (1) to 1,2 ± 0,25 m.daN.

- Check the brake pressure.

After the operation :

- Remove the checking tool [1].

- Bleed the braking circuit (See corresponding operation).

- Carry out a road test.

B3FP13VC

284

Downloaded from www.Manualslib.com manuals search engine

HANDBRAKE (Adjustment)

XSARA PICASSO - All Types

Adjustment :

Remove the handbrake trim (1).

Unclip the sound-deadening (2).

Raise and support the vehicle with the rear

wheels hanging free.

Check the correct routing of the brake cables under

the vehicle.

Apply and release the handbrake 4 times.

Set the handbrake to the 5th notch.

Tighten the nut (3) until the rear brakes are applied.

Pull the handbrake lever vigorously 4 to 5 times.

Set the handbrake to the 5th notch.

Check that the rear brakes are applied.

With the handbrake released, check that the wheels

can be turned freely by hand.

Lower the vehicle.

Refit the sound-deadening (2) and the handbrake

trim (1).

B3FP11YD

285

Downloaded from www.Manualslib.com manuals search engine

BLEEDING THE BRAKES

XSARA PICASSO - All Types

Tools

Bleeding equipment of type «LURO» or similar.

IMPERATIVE : For bleeding the secondary circuit, use ELIT, LEXIA or PROXIA diagnostic tools.

Draining.

Drain the brake fluid reservoir as empty as possible using a syringe.

Disconnect the brake fluid warning lamp connector.

Retrieve the brake fluid reservoir from its supply pipes by pulling upwards.

Finish emptying the reservoir of brake fluid.

Clean the brake fluid reservoir.

Refit the brake fluid reservoir.

Reconnect the brake fluid warning lamp connector.

Filling

Refill the reservoir with brake fluid.

WARNING : Use only the recommended hydraulic fluids.

Bleeding.

NOTE : Two technicians are required.

IMPERATIVE: During bleed operations, ensure that the level of brake fluid is maintained

in the reservoir and top it up, use only new brake fluid.

Bleed each wheel cylinder, proceeding in the following order :

Rear right hand wheel.

Front left hand wheel.

Rear left hand wheel.

Front right hand wheel.

286

Downloaded from www.Manualslib.com manuals search engine

STARTER MOTORS

SAXO

Manufacturer and Ref.

Class

1

Climate

Vehicles / models

VALEO D7E16

BOSCH A 001183 027 F

MELCO M002T13081

VALEO D6 RA 572

VALEO D7E16

H,T,C

1.1i

VC

H.,T

3

1

3

1

BOSCH A 001183 027 F

MELCO M002T13081

VALEO D6 RA 572

VALEO D7E16

1.4i (Aircon)

1.6i (Aircon)

C. VC

H, T

SAXO

BOSCH A 001 183 027F

MELCO M002T13081

VALEO D7E23

1.4i

1.6i

2

3

C

VC

BOSCH E OAL 101 390

VALEO D6RA572

1.6i 16v

VALEO D6 RA 572

H, T, C, VC

1.4i Automatic

VALEO D6RA100

VALEO D7R151

4

5

H. T. C

VC

1.5D

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

287

Downloaded from www.Manualslib.com manuals search engine

XSARA

STARTER MOTORS

Manufacturer and Ref.

Class

1

Climate

H, T

Vehicles / models

VALEO D7E16

BOSCH A 001183 027 F

MELCO M002T13081

VALEO D6 RA 572

VALEO D7E23

1.4i

1.6i

(Power steering

or aircon)

C, VC

H,T

3

2

1.4i

(Power steering

and aircon)

BOSCH E OAL 101 390

VALEO D6RA572

C, VC

1.6 i

1.6i Automatic

C, VC, H, T

VALEO D6 RA 572

XSARA

3

VALEO D6 RA 72

MELCO M000T82081

BOSCH E OAL 098 390

MELCO M 000 T 85 381

VALEO D6 RA 661

2.0i 16 v

2.0i 16 v Automatic

EW10J4

H, T

C, VC

H, T

4

3

4

2.0i 16v

XU10J4RS

BOSCH A 001 110 140 F

BOSCH A 001 111 473

C, VC

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

288

Downloaded from www.Manualslib.com manuals search engine

STARTER MOTORS

XSARA

Manufacturer and Ref.

Class

4

Climate

Vehicles / models

VALEO D6 RA 109

BOSCH A 001 111 562F

MELCO M 001 T 80381

VALEO D7 R 26

H, T

1.9D

5

6

C

MELCO M 001 T 80481

VALEO D7 R 27

VC

VALEO D6 RA 109

BOSCH A 001 111 562F

MELCO M 001 T 80381

VALEO D7 R 27

H, T

XSARA

4

2.0 HDI

90 CV

C, VC

H, T

6

5

VALEO D7 R 26

2.0 HDI

110 CV

MELCO M 001 T 80481

VALEO D7 R 27

6

C, VC

VALEO D7 R 27

2.0 HDI Automatic

110 CV

MELCO A 001 236 000

6+

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

289

Downloaded from www.Manualslib.com manuals search engine

XSARA PICASSO

STARTER MOTORS

Manufacturer and Ref.

Class

1

Climate

Vehicles / models

VALEO D7E16

BOSCH A 001 183 027F

MELCO M002T13081

VALEO D6RA572

1.6i

H, T

(Power steering

and aircon)

C, VC

3

2

VALEO D7E23

1.6i

H, T

(Power steering

and aircon)

BOSCH E OAL 101 390

VALEO D6RA572

C, VC

VALEO D6 RA 72

XSARA PICASSO

3

C. T. F

VC

MELCO M000T82081

BOSCH E OAL 098 390

MELCO M 000 T 85 381

VALEO D6 RA 109

BOSCH A 001 111 562F

MELCO M 001 T 80381

VALEO D7 R 27

1.8i 16v

2.0 HDi

4

6

H, T

C, VC

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

290

Downloaded from www.Manualslib.com manuals search engine

ALL TYPES

STARTER MOTORS

Table of classes of starters

CLASS

CLASS 2

CLASS 3

CLASS 4

CLASS 5

CLASS 6

Torque C

5.5 Nm

6 Nm

10 Nm

11.5 Nm

Maximum power

for a speed

I ≤ 275 A

I ≤ 300 A

I ≤ 430 A

I ≤ 470 A

I ≤ 500 A

of 1200 rpm

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

291

Downloaded from www.Manualslib.com manuals search engine

SAXO With power-steering

ALTERNATORS

Classes and types

Engine

Gbox

Without aircon

Climate

H, T

With aircon

Climate

H

9

8

VALEO A13 VI 279+

VALEO A13 VI 278

DENSO C 633217-40

VALEO A11 VI 55

BOSCH A120310028

VALEO A13 VI 278

DENSO C 633217-40

VALEO A11 VI 55

BOSCH A120310028

VALEO A13 VI 278

DENSO C 633217-40

VALEO A11 VI 55

BOSCH A120310028

VALEO A13 VI 278

DENSO C 633217-40

VALEO A13 VI 279+

7

8

1.1i

T, C, VC

C, VC

M

9

8

H

VALEO A13 VI 279+

VALEO A13 VI 278

DENSO C 633217-40

H, T

7

8

T, C, VC

1.4i1.6i

1.4i

C, VC

VALEO A13 VI 279+

9

H, T, C, VC

H, T

7

A

C, VC

8

9

T, C, VC

7

8

A11 VI 45

A13 VI 84

T. F

H, VC

1.5D

VALEO A11 VI 45

H, T, C, VC

7

VALEO A11 VI 55

BOSCH A120310028

VALEO A13 VI 278

DENSO C 633217-40

M

H, T

VALEO A13 VI 279+

VALEO A13 VI 278

DENSO C 633217-40

H

9

8

1.6i 16v

C, VC

T, C, VC

8

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

292

Downloaded from www.Manualslib.com manuals search engine

SAXO Police

ALTERNATORS

Classes and types

Climate

Engine

Gbox

M

Without aircon

With aircon

Climate

SAXO POLICE

11.1i/1.4i

1.5D

VALEO A13 VI 279+

9

T

M

T

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

293

Downloaded from www.Manualslib.com manuals search engine

ALTERNATORS

XSARA With power-steering

Classes and types

Engine

Gbox

Without aircon

Climate

With aircon

VALEO SG7

Climate

C, VC

VALEO SG7

7

H, T, C, VC

7

8

MELCO A005 TA 6291

VALEO SG8

T

DENSO A 115

1.4i

MELCO A005 TA 6391

VALEO A13 VI 277

VALEO A13 VI 277+

VALEO SG9

H

9

7

M

VALEO SG7

C, VC

7

8

H, T, C

VC

MELCO A005 TA 6291

VALEO SG8

DENSO A 115

8

9

DENSO A 115

T

1.6i 16v

MELCO A005 TA 6391

VALEO A13 VI 277

VALEO A13 VI 277+

VALEO SG9

MELCO A005 TA 6391

H

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

294

Downloaded from www.Manualslib.com manuals search engine

XSARA With power-steering

ALTERNATORS

Classes and types

Climate

Engine

1.6i 16v

Gbox

Without aircon

With aircon

VALEO SG8

Climate

C, VC

VALEO SG7

MELCO A005 TA 6291

VALEO SG8

7

8

T

8

DENSO A 115

MELCO A005 TA 6391

VALEO A13 VI 277

VALEO A13 VI 277+

VALEO SG9

DENSO A 115

A

H, C, VC

9

H, T

MELCO A005 TA 6391

VALEO SG7

VALEO A 13 VI 277 +

VALEO SG10

9

8

H, T

C

7

H

VALEO A 11 VI 106

MELCO A005 TA 6391

VALEO A13 VI 2 A6

VALEO SG8

VALEO A13 VI 2 A6

VALEO SG8

MELCO A005 TA 6391

DENSO A 115

2.0i 16v

M

T

8

9

MELCO A005 TA 6391

DENSO A 115

VALEO SG7

7

VC

VALEO A 11 VI 106

MELCO A005 TA 6391

VALEO A 13 VI 277 +

VALEO SG10

C, VC

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

295

Downloaded from www.Manualslib.com manuals search engine

ALTERNATORS

XSARA With power-steering

Classes and types

Engine

Gbox

Without aircon

Climate

H, T

With aircon

Climate

T, C, VC

VALEO A 11 VI 191

VALEO SG7

VALEO A13 VI 203

VALEO SG8

8

9

7

8

VALEO SG7 CPLE

VALEO A13 VI 203

VALEO SG8

MELCO A002 TB 4791

VALEO A13 VI 204+

VALEO SG10

1.9D

C, VC

MELCO A002 TB 4791

VALEO A13 VI 204+

VALEO SG10

MELCO A002 TB 4891

VALEO A13 VI 204+

VALEO SG10

H

M

9

H

MELCO A002 TB 4891

MELCO A003 TA 0891

BOSCH A 120 51 611

VALEO SG15 CPLE

VALEO A14 VI127+

MELCO A004TF0091

MELCO A002 TB 4891

MELCO A003 TA 0891

BOSCH A 120 51 611

VALEO SG15 CPLE

VALEO A14 VI127+

MELCO A004TF0091

2.0 HDI

90CV

110 CV

12

15

T, C, VC

15

T, C, VC

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

296

Downloaded from www.Manualslib.com manuals search engine

XSARA PICASSO With power-steering

ALTERNATORS

Classes and types

Engine

Gbox

Without aircon

Climate

H

With aircon

Climate

H

NC

VALEO A11 VI 191

VALEO SG7

VALEO A11 VI 191

VALEO SG7

7

T, C, VC

C

T

VALEO SG7 CPLE

VALEO A13 VI 204+

VALEO SG10

1.6i

M

9

8

MELCO A002 TB 4891

VALEO A13 VI 203

VALEO SG8

VC

MELCO A002 TB 4791

CLIMATE : T (Temperate), H (Hot), C (Cold), VC (Very cold)

297

Downloaded from www.Manualslib.com manuals search engine

Electrical System for Your Citroen Xsara SUV Second Generation (1997-2006)

Related Topics

Popular Owner Manuals

Latest Owner Manuals