Get Technical data Guide for Volkswagen Polo SUV Fourth Generation (2001-2009)

12/29/2015

Bedienungsanleitung < Service & Zubehör < Volkswagen Deutschland

For diesel engines: is diesel with a low sulphur level available?

Are the correct engine oil ( Engine oil Engine oil Engine compartment Engine oil_3 Oil see Engine oil_3 ) and other service fluids that

comply with Volkswagen specifications available in the destination country?

Will the factory-fitted navigation system work with the navigation data available in the destination country?

Are special tyres necessary for travelling in the destination country?

NOTICE

Volkswagen is not responsible for any vehicle damage caused by low-quality fuel, inadequate servicing work or lack of Genuine Parts.

Driving through water on roads

First read and observe the introductory information and safety warnings →

ꢀ

Introduction

Please follow these rules to help prevent damage to your vehicle when driving through water, for example if the road is flooded:

Check the depth of the water before driving through it. The water level must be no higher than the lower edge of the vehicle body → ꢀ.

Do not drive faster than walking speed.

Never stop the vehicle, reverse or switch off the engine while in water.

Oncoming vehicles create waves that could increase the water level for your vehicle to such an extent that it is not safe to drive through the

water.

When driving through water, always switch start/stop system off manually → Pull-away assist systems ꢀ .

WARNING

After driving through water, mud, slush etc., the brakes may react slowly and the braking distance will be increased as the brake discs and pads

will be wet, or possibly iced up in winter.

You can dry and de-ice the brakes by performing careful braking manoeuvres. Make sure that you do not endanger any other road users or

violate any legal regulations when doing so.

Avoid abrupt and sudden braking manoeuvres directly after driving through water.

NOTICE

If you drive through water, parts of the vehicle, such as the engine, drive train, running gear and vehicle electrics, could sustain severe

damage.

Never drive through salt water as salt can cause corrosion. Rinse all components that have been exposed to salt water immediately with

fresh water.

Technical data

Introduction

This chapter contains information on the following subjects:

→ Vehicle identification data ꢀ

→ Engine data ꢀ

→ Dimensions ꢀ

3/136

12/29/2015

→ Performance figures ꢀ

Bedienungsanleitung < Service & Zubehör < Volkswagen Deutschland

The vehicle data sticker in the service schedule or the vehicle registration documents show which engine is installed in your vehicle.

All data in the official vehicle documents take precedence over these data. All the information provided in this manual applies to the basic model.

The figures may be different if additional equipment is fitted, for different models, for special vehicles and for other countries.

Additional information and warnings:

Transporting → Transporting items ꢀ

Driving with respect for the environment → Driving with respect for the environment ꢀ

Fuel → Fuel ꢀ

Engine oil → Engine oil ꢀ

Engine coolant → Coolant ꢀ

Wheels and tyres → Wheels and tyres ꢀ

Consumer information → Consumer information ꢀ

WARNING

Ignoring or exceeding the values given for the weights, payloads, vehicle dimensions and maximum speed could lead to accidents and serious

injuries.

Vehicle identification data

Fig. 19 A: vehicle data sticker: example shows a vehicle with engine code CPTA ꢀ. B: type plate

4/136

12/29/2015

Bedienungsanleitung < Service & Zubehör < Volkswagen Deutschland

Fig. 20 Vehicle identification number

First read and observe the introductory information and safety warnings →

ꢀ

Introduction

Vehicle identification number (VIN)

The vehicle identification number can be read from outside the vehicle through a viewer in the windscreen → Fig. 20ꢀ (arrow). The viewer is

located in the lower corner of the windscreen. The vehicle identification number is also stamped on the right water drain channel. The water

drainage channel is located between the suspension turret and wing. You have to open the bonnet

number → Preparation for working in the engine compartment ꢀ .

to gain access to the vehicle identification

The vehicle identification number can be displayed in the infotainment system using the

function buttons → Menu and system settings (SETUP) ꢀ .

button and the

and Service

Vehicle data sticker

The vehicle data sticker → Fig. 19ꢀ A is in the spare wheel well area in the luggage compartment. It contains the following data:

Vehicle identification number (chassis number)

Vehicle type, engine power, gearbox type

Engine and gearbox code, paint number, interior equipment. In the example, the engine code is CPTA → Fig. 19ꢀ.

Optional extras, PR numbers

These vehicle data are also contained in the service schedule.

Type plate

The type plate → Fig. 19ꢀ B can be seen on the lower part of the door pillar when the door is open. Vehicles for certain export countries do not

have a type plate.

The type plate contains the following data:

Permission

Gross vehicle weight rating

Gross combination weight (vehicle plus trailer)

5/136

12/29/2015

Bedienungsanleitung < Service & Zubehör < Volkswagen Deutschland

Gross axle weight rating, front

Gross axle weight rating, rear

Engine data

First read and observe the introductory information and safety warnings →

ꢀ

Introduction

For reasons of vehicle registration and vehicle taxation, the power output and performance of some engines may vary in some countries from the

information given in this booklet.

Petrol engines

Engine power

Injection

technology

EC

Maximum torque

Cylinders

Capacity

44 kW at

5,000 – 6,000 rpm

CHYA

CHYB

CJZC

CJZD

95 Nm at

3,000 – 4,300 rpm

3 cylinders,

999 ccm

55 kW at

6,200 rpm

66 kW at

4,400 – 5,400 rpm

160 Nm at

TSI^®

1,400 – 3,500 rpm

4 cylinders,

1,197 ccm

81 kW at

4,600 – 5,600 rpm

175 Nm at

1,400 – 4,000 rpm

Diesel engines

Engine power

Injection

technology

EC

Maximum torque

Cylinders,

Capacity

CYZB

CUSA

55 kW at

3,000 – 3,750 rpm

210 Nm at

1,500 – 2,000 rpm

TDI^®

3 cylinders,

1,422 ccm

66 kW at

3500 rpm

230 Nm at

1,500 – 2,500 rpm

CUSB

Dimensions

6/136

12/29/2015

Bedienungsanleitung < Service & Zubehör < Volkswagen Deutschland

Fig. 21 Dimensions

First read and observe the introductory information and safety warnings →

The data in the table apply to the most basic German model.

ꢀ

Introduction

The specified values can vary due to different tyre and wheel sizes, if additional equipment is fitted, for different model versions, for retrofitted

accessories, and for special vehicles. They can also vary in vehicles that have been manufactured for other countries.

Polo

BlueMotion

Cross Polo

Key to → Fig. 21ꢀ:

Ⓐ

Ⓑ

Width (from one exterior mirror to the other)

1,901 mm

Width

1,682 mm

1,698 mm

Front track

Rear track

1,441 mm – 1,465 mm 1,453 mm – 1,457 mm 1,438 mm – 1,460 mm

1,434 mm – 1,456 mm 1,446 mm – 1,450 mm 1,436 mm – 1,459 mm

Ⓒ

Height to the upper edge of the roof at kerb weight^a)

Height at kerb weight^a)with navigation aerial

1,453 mm

1,461 mm

–

1,456 mm

1,463 mm

–

1,474 mm

1,480 mm

1,488 mm

Ⓓ

Height to the upper edge of the roof at kerb weight^a)

Length with fitted towing bracket (when factory-fitted)

Length (from bumper to bumper)

Ⓔ

Ⓕ

Ⓖ

Ⓗ

4,064 mm – 4,074 mm

3,972 mm – 4,010 mm

2,456 mm

4,064 mm

3,970 mm

2,455 mm

145 mm

4,077 mm

3,987 mm

2,459 mm

175 mm

Wheelbase

Ground clearance when drive-ready^b)between the axles

Height with open bonnet and kerb weight^a)

143 mm

Ⓘ

Ⓙ

1,759 mm

2,000 mm

1,762 mm

2,003 mm

1,783 mm

2,019 mm

Height with open tailgate at kerb weight^a)

Turning circle diameter

Approx. 10.6 m

7/136

12/29/2015

Bedienungsanleitung < Service & Zubehör < Volkswagen Deutschland

NOTICE

Take care when driving in car parks with protruding kerbstones or bollards. Objects that protrude from the ground can damage the bumper

and other components when parking the vehicle.

Drive carefully through dips in the road, over driveways, ramps, kerbstones and other objects. Low-lying vehicle components such as the

bumper, spoiler and parts of the running gear, engine or exhaust system could be damaged.

^a)Kerb weight without driver, without payload.

^b)Kerb weight with driver (75 kg) and service fluids.

Performance figures

First read and observe the introductory information and safety warnings →

ꢀ

Introduction

For reasons of vehicle registration and vehicle taxation, the power output and performance of some engines may vary in some countries from the

information given in this booklet.

Petrol engines

Engine power

EC

Gearbox type

Maximum speed

161 km/h^a)

44 kW

CHYA

173 km/h^a)

55 kW

66 kW

81 kW

CHYB

CJZC

CJZD

MG5

184 km/h^b)

196 km/h^b)

MG6

Diesel engines

Engine power

EC

Gearbox type

Maximum speed

173 km/h

CYZB

CUSA

55 kW

MG5

184 km/h

66 kW

CUSB

c)

DSG^®7

–

When the performance figures were measured, the vehicle was not fitted with any equipment that could reduce performance, e.g. a roof

carrier or mud flaps.

^a)Maximum speed is reached in 5th gear.

^b)Maximum speed is reached in 4th gear.

^c)Figures were not available at time of publication.

Opening and closing

8/136

Technical data for Your Volkswagen Polo SUV Fourth Generation (2001-2009)

Related Topics

Popular Owner Manuals

Latest Owner Manuals