Get In Case of Emergency -> Tyre Repair Kit Guide for Fiat 600 SUV Second Generation (2023-2026)

TYRE REPAIR KIT

(where provided)

Made up of a compressor and a

sealant cartridge, it allows you to carry

out a temporary repair of the tyre so

that you can drive to the nearest

garage.

Minor damage to the tyre tread can

be repaired with the tyre repair kit. It

is designed to repair most punctures

located on the tyre tread.

Do not remove foreign bodies from the

tyres.

288

JJ000667

290

JJ000658

remove the electrical connection

cable (2) fig. 290 and air hose (1) from

the stowage compartments on the

underside of the compressor

Tyre damage exceeding 4 mm or that

is at tyre's sidewall cannot be repaired

with the tyre repair kit.

TIRE SEALANT

284) 285) 286)

118)

In the case of a flat tyre:

apply the parking brake and engage

the reverse gear or P

289

JJ000724

remove the sealant bottle and the

compressor

pull speed limit label from the top of

the sealant bottle and place it in driver's

visible area

the tyre repair kit is in the load

compartment below the floor cover,

For Electric versions, see

fig. 288

291

JJ000702

For other versions, the

join the sealant bottle to the

compressor (1) fig. 291 and rotate the

bottle 1/4 turn clockwise (2)

compressor is in position (1)

fig. 289, the bottle is under the

cover (2)

223

For checking the tyre pressure:

screw one end of the compressor air

hose directly onto tyre valve and the

other end to the compressor, without

connecting the sealant bottle, fig. 294

bar

psi

292

F6S0116

293

JJ000703

unscrew the valve cap from the

defective tyre and screw the filler hose

to the tyre valve (1) fig. 292

screw the other end of the filler hose

to the sealant bottle (2) fig. 292

connect the compressor plug

to the 12V power outlet. To avoid

discharging the conventional battery,

we recommend running the engine

NOTE The vehicle's electric system

allows the connection of the

compressor to the 12 V power supply

for long enough to repair a tyre after a

puncture.

check the tyre pressure on the

gauge (1) fig. 293: if in 15 minutes the

indicator is not in the green area, the

tyre is too badly damaged. In this case

turn the switch (3) fig. 292 to position 0

(OFF) and seek the assistance of a Fiat

Dealership

If the indicator reaches the green

area, turn the switch (3) fig. 292 to

position 0 (OFF), disconnect the

electrical connection cable from the

12V power outlet

detach the tyre repair kit from the

tyre valve and reapply the valve cap

remove sealant bottle from

compressor by rotating it 90°

anticlockwise and remove any excess

sealant using a cloth

294

F6S0192

turn the switch (3) fig. 292 to position

I (ON)

If the indicator on the gauge (1) fig. 293

reaches the prescribed pressure (see

"Wheels and tyres" chapter) within 15

minutes, stop the compressor turning

the switch (3) fig. 292 to position I (ON),

unscrew the compressor air hose from

the tyre valve and reapply the valve

cap.

turn the switch (3) fig. 292 to position

I (ON): all the sealant is pumped into

the tyre, then the tyre is being inflated

If the indicator doesn't reach the

prescribed pressure within 15 minutes,

turn the switch (3) to position 0 (OFF)

and seek the assistance of a Fiat

Dealership.

Start driving in maximum 1 minute.

Maximum speed: 80 km/h (50 mph).

After driving approximately 15 minutes,

stop and check the tyre pressure.

Disconnect the compressor from the

12V power outlet.

224

Stow away tyre repair kit in load

compartment.

JUMP STARTING

excessively damaged and that the rim is

in good condition, otherwise do not use

it and call roadside assistance. Do not

remove foreign bodies from the tire. Do

not let the compressor turned on for more

than 15 consecutive minutes - overheating

hazard.

285) The information required by the

applicable regulation is indicated on the

Tyre repair kit cartridge label. Carefully

read the cartridge label before use and

avoid improper use. The Tyre repair kit

should be used by adults and cannot be

used by children.

WARNING Charging should be

slow at a low ampere rating for

approximately 24 hours. Regardless

of the duration of the operation, it is

always recommended to disconnect

the battery from the device as soon as

charging is complete to avoid potential

damage.

The vehicle can be used for maximum

1000 km (620 mi) at a maximum

speed: 80 km/h (50 mph). Tyre repair

kit provides a temporary repair,

therefore the tire must be examined

and repaired by a specialist as soon as

possible.

If the indicator doesn't reach the

prescribed pressure within 15 minutes

or if a loss of pressure is found after the

second check the vehicle must not be

used. Stop the compressor and seek

the assistance of a Fiat Dealership.

If the vehicle's battery is flat, the engine

can be started using a backup battery

(either external or from another vehicle)

and jump leads or using a battery

booster.

286) If the valve is positioned at 12

o'clock, turn the tyre forwards or

backwards by a quarter of a turn.

A vehicle with a discharged

conventional battery can be started

using jump leads and the conventional

battery of another vehicle.

WARNING

WARNING The driving characteristics

of the repaired tyre are severely

affected, therefore have this tyre

replaced. If unusual noise is heard or

the compressor becomes hot, turn

compressor off for at least 30 min. The

built-in safety valve opens at a pressure

of 600 kPa (6 bar).

118) The sealant fluid is effective with

external temperatures from -30°C to

+50°C. The sealant fluid has an expiry date

and must be replaced periodically. It is

possible to repair tyres with damage on

the tread up to a maximum diameter of 6

mm. Show the cartridge and the label to

the personnel who must handle the tyre

treated with the Tyre repair kit.

287) 288) 289) 290) 291) 292)

119) 120) 121) 122) 123)

Never expose the conventional

battery to naked flames or sparks.

A discharged conventional battery

can already freeze at a temperature of

0 °C. Defrost the frozen battery before

connecting jump leads.

Use a booster battery with the same

voltage (12 V). Its capacity (Ah) must

not be much less than that of the

discharged conventional battery.

IMPORTANT

WARNING

284) WARNING! Do not exceed 80 km/h

(50 mph). Avoid sudden acceleration or

braking. The Tyre repair kit provides a

temporary repair, therefore the tire must

be examined and repaired by a specialist

as soon as possible. Before using the

Tyre repair kit, make sure that the tire isn't

7) Dispose of the bottle and the sealant

liquid properly. Have them disposed of

in compliance with national and local

regulations.

225

In Case of Emergency -> Tyre Repair Kit for Your Fiat 600 SUV Second Generation (2023-2026)

Related Topics

In Case of Emergency

Popular Owner Manuals

Latest Owner Manuals