Get Maintenance -> Scheduled maintenance services Guide for Hyundai Kona SUV Second Generation (2023-2026)

Scheduled Maintenance Services

Follow Normal Maintenance Schedule if the vehicle is usually operated where none of the

following conditions apply. If any of the following conditions apply, you must follow the

Maintenance Under Severe Usage Conditions.

• Repeated driving short distance of less than 5 miles (8 km) in normal temperature or

less than 10 miles (16 km) in freezing temperature

• Extensive engine idling or low speed driving for long distances

• Driving on rough, dusty, muddy, unpaved, graveled or salt-spread roads

• Driving in areas using salt or other corrosive materials or in very cold weather

• Driving in heavy dust conditions

• Driving in heavy traffic area

• Driving on uphill, downhill, or mountain road repeatedly

• Towing a trailer or using a camper, or driving with loads on the roof

• Driving as a patrol car, taxi, other commercial use of vehicle towing

• Frequently driving under high speed or rapid acceleration/deceleration

• Frequently driving in stop-and-go condition

• Engine oil usage which is not recommended (Mineral type, Semi-synthetic, Lower

grade spec, etc.)

If your vehicle is operated under the above conditions, you should inspect, replace or refill

more frequently than the following Normal Maintenance Schedule. After the periods or

distance shown in the chart, continue to follow the prescribed maintenance intervals.

NOTICE

After driving more than 10 years or 100,000 miles, use severe maintenance schedule.

624 Maintenance

Information

• As it is normal for engine oil to be consumed during driving, the engine oil level should

be checked on regular basis.

• The engine oil change interval for normal operating conditions is based on the use of

the recommended engine specification. If the recommended engine oil specification

is not used, then replace the engine oil according to the maintenance schedule under

severe operating conditions.

• The vehicle may be equipped with the Oil Life Management System that predicts

engine oil life based on the driver's driving history and alerts the driver to change

engine oil.

- If the deterioration of the engine oil increases depending on the driver's driving

severity, the remaining oil life alert appears on the instrument cluster before the

normal engine oil replacement interval. Have the engine oil and filter changed by an

authorized HYUNDAI dealer.

- Oil Life Management System works when the recommended engine oil is used. So,

if recommended engine oil is not used, replace the engine oil according to the

maintenance schedule under severe usage condition. Also, check the amount of

engine oil regularly as this system assumes that the engine oil is being filled normally.

- Always reset the remaining engine oil life whenever the engine oil is changed.

Otherwise, the indication of remaining Oil life in the Oil Life Management System

may not be accurate. To reset the Oil Change Reminder, select "RESET" from the

infotainment system. Then, select " Yes" when the message “Has the engine oil been

changed? Press [Yes] to reset the oil life.” appears on the screen.

- If there is no alert until the maximum maintenance interval, have your vehicle

inspected by an authorized HYUNDAI dealer.

Normal maintenance schedule

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

Number of months or driving distance, whichever comes first

108 120

144

132

156

104

Months

12 24 36 48 60 72 84 96

MAINTENANCE

INTERVALS

Miles ×

1,000

8

16 24 32 40 48 56 64 72 80 88 96

104

130 143 156 169

117

Km × 1,000 13 26 39 52 65 78 91

MAINTENANCE ITEM

At first, inspect at 48,000 miles (78,000 km) or 72 months.

After that, inspect every 8,000 miles (13,000 km) or 12

months

*1

Drive belts

Smartstream

1.6 T-GDi

Engine oil and

engine oil filter

Replace every 8,000 miles (13,000 km) or 12 months

*2*3

Maintenance 625

Number of months or driving distance, whichever comes first

108 120

144

132

156

104

Months

12 24 36 48 60 72 84 96

MAINTENANCE

INTERVALS

Miles ×

1,000

8

16 24 32 40 48 56 64 72 80 88 96

104

130 143 156 169

117

Km × 1,000 13 26 39 52 65 78 91

MAINTENANCE ITEM

Smartstream

2.0

ATKINSON

Replace every 8,000 miles (13,000 km) or 12 months

Add every 8,000 miles (13,000 km) or 12 months

*4

Fuel additives

Air cleaner filter

I

R

I

R

I

R

I

R

I

*1: The drive belt should be replaced when cracks occur or tension is reduced excessively.

*2: Requires <API SN PLUS (or above) Full synthetic> grade engine oil. If a lower grade engine oil (mineral type,

semi- synthetic, lower grade spec, etc.) is used, replace the engine oil and engine oil filter as indicated in

maintenance under severe usage conditions.

*3: Never add any additives to the engine oil. Engine oil additives can change the properties of engine oil and may

cause serious engine failure.

*4: If TOP TIER Detergent Gasoline is not available, one bottle of additive is recommended. Additives are available

from your authorized HYUNDAI dealer along with information on how to use them. Do not mix other additives.

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

Number of months or driving distance, whichever comes first

108 120

144

132

156

104

Months

12 24 36 48 60 72 84 96

MAINTENANCE

INTERVALS

Miles ×

1,000

8

16 24 32 40 48 56 64 72 80 88 96

104

130 143 156 169

117

Km × 1,000 13 26 39 52 65 78 91

MAINTENANCE ITEM

Smartstream

1.6 T-GDi

Replace every 48,000 miles (78,000 km)

Replace every 96,000 miles (156,000 km)

*1

Spark plugs

Smartstream

2.0

ATKINSON

Vapor hose, fuel filler cap and

fuel tank

I

626 Maintenance

Number of months or driving distance, whichever comes first

108 120

144

132

156

104

Months

12 24 36 48 60 72 84 96

MAINTENANCE

INTERVALS

Miles ×

1,000

8

16 24 32 40 48 56 64 72 80 88 96

104

130 143 156 169

117

Km × 1,000 13 26 39 52 65 78 91

MAINTENANCE ITEM

Fuel tank air filter

I

At first, Inspect at 8,000 miles (13,000 km) or 6 months

After that, Inspect every 20,000 miles (32,000 km) or 24

months

*1

Intercooler, in/out hose

Fuel lines, hoses and

connections

I

*2

Fuel filter

*1: For your convenience, it can be replaced prior to its interval when you do maintenance of other items.

*2: Fuel filter is considered to be maintenance free but the quality of fuel used may impact the frequency of

maintenance needed. If there are some important safety matters like fuel flow restriction, surging, loss of

power, hard starting problem, etc., replace the filter immediately regardless of maintenance schedule. Consult

an authorized HYUNDAI dealer for details.

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

Maintenance 627

Number of months or driving distance, whichever comes first

108 120

144

132

156

104

Months

12 24 36 48 60 72 84 96

MAINTENANCE

INTERVALS

Miles ×

1,000

8

16 24 32 40 48 56 64 72 80 88 96

104

130 143 156 169

117

Km × 1,000 13 26 39 52 65 78 91

MAINTENANCE ITEM

At first, replace at 120,000 miles (200,000 km) or 120

months. After that, replace every 24,000 miles (39,000

km) or 24 months

Engine coolant

Battery condition

I

Brake lines, hoses and

connections

Inspect every 8,000 miles (13,000 km) or 12 months,

Replace every 48,000 miles (78,000 km) or 48 months

Brake fluid

Disc brakes and pads

I

Steering gear rack, linkage and

boots

Driveshaft and boots

Rotate Tires (includes tread wear

inspection and tire pressure

check)

Rotate tires every 8,000 miles (13,000 km) or 12 months

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

628 Maintenance

Number of months or driving distance, whichever comes first

108 120

144

132

156

104

Months

12 24 36 48 60 72 84 96

MAINTENANCE

INTERVALS

Miles ×

1,000

8

16 24 32 40 48 56 64 72 80 88 96

104

130 143 156 169

Km × 1,000 13 26 39 52 65 78 91

MAINTENANCE ITEM

117

Suspension mounting bolts

Air conditioner refrigerant

Air conditioner compressor

Cabin air filter

I

R

Automatic

Transmission fluid

*1

Smartstream

1.6 T-GDi

No check, No service required

Intelligent Variable

Transmission fluid

*1

Smartstream

2.0

ATKINSON

*1

I

Transfer case oil (AWD)

*1

I

Rear differential oil (AWD)

Propeller shaft (AWD)

I

Exhaust pipe and muffler

I

*1: Automatic Transmission/Intelligent Variable Transmission fluid, transfer case oil, and rear differential oil should

be changed anytime they have been submerged in water.

Maintenance under severe usage and low mileage conditions

The following items must be serviced more frequently on the vehicles mainly used under

severe and low mileage driving conditions. Refer to the chart below for the appropriate

maintenance intervals.

R: Replace

I: Inspect and if necessary, adjust, correct, clean or replace

Maintenance 629

Maintenance

operation

Driving

condition

Maintenance item

Maintenance intervals

Smartstream

Replace every 5,000 miles

(8,000 km) or 6 months

R

D, H, I, L

1.6 T-GDi

Engine oil and

engine oil

filter

Smartstream

2.0

ATKINSON

Replace every 5,000 miles

(8,000 km) or 6 months

A, B, C, D, E, F,

G, H, I, J, K, L

Replace more frequently

Air cleaner filter

Spark plugs

R

I

C, E

depending on the condition

Replace more frequently

depending on the condition

A, B, F, G, H, I,

K

Steering gear rack, linkage

and boots

Inspect more frequently

depending on the condition

C, D, E, F, G

Inspect more frequently

depending on the condition

C, D, E, F, G,

H, I

Suspension mounting bolts

I

Disc brakes and pads, calipers

and rotors

Inspect more frequently

depending on the condition

I

C, D, E, G, H

Inspect more frequently

C, D, E, F, G,

H, I, J

Driveshaft and boots

Cabin air filter

I

depending on the condition

Replace more frequently

depending on the condition

R

C, E, G

Automatic

Smartstream

Transmission

1.6 T-GDi

Replace every 60,000 miles

(100,000 km)

R

A, C, E, F, G, I

fluid

Intelligent

Smartstream

Variable

Replace every 55,000 miles A, C, D, E, F, G,

(90,000 km) H, I, K

2.0

Transmission

ATKINSON

fluid

Replace every 72,000 miles C, D, E, G, H, I,

(120,000 km)

Transfer case oil (AWD)

Rear differential oil (AWD)

Propeller shaft

R

I

J

Replace every 72,000 miles C, D, E, G, H, I,

(120,000 km)

J

Inspect more frequently

depending on the condition

C, D, E, F, G,

H, I, J

630 Maintenance

Severe driving conditions

• A: Repeatedly driving short distance of less than 5 miles (8 km) in normal temperature

or less than 10 miles (16 km) in freezing temperature

• B: Extensive engine idling or low speed driving for long distances

• C: Driving on rough, dusty, muddy, unpaved, graveled or salt-spread roads

• D: Driving in areas using salt or other corrosive materials or in very cold weather

• E: Driving in the heavy dust conditions

• F: Driving in heavy traffic

• G: Driving on uphill, downhill, or mountain roads

• H: Using for towing or camping, and driving with loading on the roof

• I: Driving for patrol car, taxi, or other commercial use

• J: Frequently driving under high speed or rapid acceleration/deceleration

• K: Frequently driving in stop-and-go conditions

• L: Engine oil usage which is not recommended (Mineral type, Semi-synthetic, Lower

grade spec, etc.)

Maintenance 631

Maintenance -> Scheduled maintenance services for Your Hyundai Kona SUV Second Generation (2023-2026)

Related Topics

Popular Owner Manuals

Latest Owner Manuals