2010-2017 Volvo V60 SUV Maintenance and service -> Fuses User Manual
MyCarUserManual.com
USER MANUALS FOR EVERY MAKE & MODEL

Maintenance and service -> Fuses for Your Volvo V60 SUV First Generation (2010-2017)

09 Maintenance and service
Fuses
09
350
General
All electrical functions and components are
protected by a number of fuses in order to pro-
tect the car's electrical system from damage by
short circuiting or overloading.
If an electrical component or function does not
work, it may be because the component's fuse
was temporarily overloaded and failed. If the
same fuse fails repeatedly then there is a fault
in the circuit. Volvo recommends that you visit
an authorised Volvo workshop for checking.
Changing
1. Look in the fuse diagram to locate the fuse.
2. Pull out the fuse and check from the side
to see whether the curved wire has blown.
3. If this is the case, replace it with a new fuse
of the same colour and amperage.
WARNING
Never use a foreign object, or a fuse with an
amperage higher than that specified when
replacing a fuse. This could cause signifi-
cant damage to the electrical system and
possibly lead to fire.
Location, fuse boxes
Central electrical unit locations in a left-hand
drive car. In a right-hand drive car the central
electrical units under the glovebox change
sides.
Engine compartment
Under the glovebox
Under the glovebox
Cargo area under the cargo floor
Engine compartment cold zone (only Start/
Stop*)
09 Maintenance and service
Fuses
09
``
351
Engine compartment
09 Maintenance and service
Fuses
09
352
* Option/accessory, for more information, see Introduction.
General fuses, engine compartment
On the inside of the cover there are tweezers
that facilitate the procedure for the removal
and fitting of fuses.
Positions (see preceding illustration)
Engine compartment, upper
Engine compartment, front
Engine compartment, lower
These fuses are all located in the engine com-
partment box. The fuses in (C) are located
under (A).
On the inside of the cover is a label that shows
the location of the fuses.
•
Fuses 1-7 and 42-44 are of the "Midi Fuse"
type and must only be replaced by a work-
shop
1
.
•
Fuses 8-15 and 34 are of the "JCASE" type
and should be replaced by a workshop
1
.
•
Fuses 16-33 and 35-41 are of the "Mini
Fuse" type.
Function A
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox
A
50
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox
50
Primary fuse for central electri-
cal unit in cargo area
A
60
Primary fuse for central electri-
cal unit in passenger compart-
ment with fuse box A under the
glovebox
A
60
Primary fuse for central electri-
cal unit in passenger compart-
ment with fuse box A under the
glovebox
A
60
- -
PTC element, air preheater*
A
100
Headlamp washers* 20
Windscreen wipers 30
Function A
Parking heater* 25
Ventilation fan
A
40
- -
ABS pump 40
ABS valves 20
- -
Headlamp levelling*; Active
Xenon headlamps - ABL*
10
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox
20
ABS 5
Speed related power steering* 5
Engine control module; Trans-
mission control module; Air-
bags
10
Heated washer nozzles* 10
1
An authorised Volvo workshop is recommended.
09 Maintenance and service
Fuses
09
``
* Option/accessory, for more information, see Introduction.
353
Function A
- -
Headlamp control 5
- -
- -
- -
Internal relay coils 5
Auxiliary lamps* 20
Horn 15
Relay coil in main relay for
engine management system;
Engine control module (5, 6-cyl.
petrol)
10
Transmission control module 15
Solenoid clutch A/C (not 5-cyl.
diesel); Coolant pump (5-cyl.
diesel Start/Stop)
15
Function A
Relay coil in relay for solenoid
clutch A/C (not 5-cyl. diesel);
Relay coil in relay for coolant
pump (5-cyl. diesel Start/Stop);
Relay coils in central electrical
unit in engine compartment cold
zone (Start/Stop)
5
Start relay
A
30
Ignition coils (4-cyl. petrol);
Glow control module (5-cyl. die-
sel)
10
Ignition coils (5, 6-cyl. petrol);
Capacitor (6-cyl.)
20
Engine control module (petrol) 10
Engine control module (diesel) 15
Function A
Valves (1.6 l petrol); Mass air
flow sensor (1.6 l petrol)
Mass air flow sensor (D4162T);
Control valve, fuel flow
(D4162T)
10
Mass air flow sensor (5-cyl. die-
sel, 6-cyl.); Control valves (5-
cyl. diesel); Injectors (5, 6-cyl.
petrol); Engine control module
(5-cyl. petrol, 6-cyl.)
15
Solenoid clutch A/C (5, 6-cyl.);
Valves, Engine control module
(6-cyl.) Solenoids (6-cyl. without
turbo); Actuator motors, intake
manifold (6-cyl. without turbo);
Mass air flow sensor (4-cyl. 2.0
l petrol, 5-cyl. petrol); Oil level
sensor (5-cyl. diesel)
Coolant pump (D4162T)
10
Lambda-sonds (4-cyl. petrol);
Lambda-sond (diesel); Control
module, radiator roller cover
(manual 5-cyl. 2.0 l diesel)
10
EVAP valve (5, 6-cyl. petrol);
Lambda-sonds (5, 6-cyl. petrol)
15
09 Maintenance and service
Fuses
09
354
Function A
Coolant pump (1.6 l petrol Start/
Stop, 5-cyl. petrol Start/Stop);
Crankcase ventilation heater (5-
cyl. Petrol); Oil pump automatic
gearbox (5-cyl. petrol Start/
Stop)
10
Diesel filter heater 20
Control module, radiator roller
cover (5-cyl. petrol)
5
Crankcase ventilation heater (5-
cyl. diesel); Oil pump automatic
gearbox (5-cyl. diesel Start/
Stop)
10
Glow plugs (diesel) 70
Cooling fan (4-cyl., 5-cyl. petrol) 60
Cooling fan (6-cyl., 5-cyl. diesel) 80
Electro-hydraulic power steer-
ing
100
A
For cars with the Start/Stop function this fuse location is
empty - see instead page 359.
09 Maintenance and service
Fuses
09
``
* Option/accessory, for more information, see Introduction.
355
Under the glovebox
Positions
On the inside of the cover is a label that shows
the location of the fuses in fuse box A.
Box A Function A
Primary fuse for audio con-
trol module*; Primary fuse
for fuses 16-20: Infotain-
ment
40
- -
- -
Box A Function A
- -
- -
Door handle (Keyless*) 5
- -
Control panel, driver's door 20
Control panel, front passen-
ger door
20
Box A Function A
Control panel, rear passen-
ger door, right
20
Control panel, rear passen-
ger door, left
20
Keyless* 7.5
Power seat driver's side* 20
Power seat passenger side* 20
09 Maintenance and service
Fuses
09
356
* Option/accessory, for more information, see Introduction.
Box A Function A
- -
Infotainment control module 5
Audio control unit (ampli-
fier)*
Digital radio*; TV*
10
Audio 15
Telematics*; Bluetooth* 5
- -
Sunroof*; Interior lighting
roof; Climate sensor*;
Damper motors, air intake
5
12 V socket, tunnel console 15
Seat heating, rear right* 15
Seat heating, rear left* 15
- -
Seat heating (passenger
side)
15
Seat heating (driver's side) 15
Box A Function A
Parking assistance*; Park-
ing camera*; Towbar control
module *
BLIS*
5
AWD control module* 15
Active chassis Four-C* 10
Box B Function A
Rear window wiper 15
- -
Interior lighting; Driver's
door control panel, power
windows; Power seats,
front*; Remote controlled
garage door opener*
7.5
Information display (DIM) 5
Adaptive cruise control,
ACC*; collision warning sys-
tem*
10
Interior lighting; Rain sensor 7.5
Steering wheel module 7.5
Box B Function A
Central locking system, fuel
filler flap
10
Rear window washer 15
Windscreen washers 15
Unlocking, tailgate 10
Folding head restraint* 10
Fuel pump 20
Movement detector alarm*;
Climate panel
5
Steering lock 15
Siren alarm*; Data link con-
nector OBDII
5
- -
Airbags 10
Collision warning system* 5
Accelerator pedal sensor,
PTC element air preheater*;
Dimming, interior rearview
mirror*; Seat heating, rear*
7.5
09 Maintenance and service
Fuses
09
``
* Option/accessory, for more information, see Introduction.
357
Box B Function A
- -
Brake light 5
Sunroof* 20
Immobiliser 5
09 Maintenance and service
Fuses
09
358
* Option/accessory, for more information, see Introduction.
Cargo area
Positions
Function A
Electric parking brake, left 30
Electric parking brake, right 30
Rear window defroster 30
Trailer socket 2* 15
Function A
- -
12 V socket, cargo area 15
- -
- -
Function A
- -
- -
Trailer socket 1* 40
- -
09 Maintenance and service
Fuses
09
``
* Option/accessory, for more information, see Introduction.
359
Engine compartment, cold zone - Start/Stop*
Location of fuses for the Start/Stop function.
•
Fuses A1 and A2 are of the "MEGA Fuse"
type and must only be replaced by a work-
shop
2
.
•
Fuses 1-11 are of the "Midi Fuse" type and
must only be replaced by a workshop
2
.
•
Fuse 12 is of the "Mini Fuse" type.
For more information on Start/Stop - see
page 127.
Positions
Function A
Main fuse for central electrical
unit in the engine compartment
175
Function A
Main fuse for central electronic
module (CEM) with fuse box B
under the glovebox, central
electrical unit in passenger
compartment with fuse box A
under the glovebox, central
electrical unit in cargo area
175
PTC element, air preheater* 100
2
An authorised Volvo workshop is recommended.
09 Maintenance and service
Fuses
09
360
Function A
Primary fuse for the central elec-
tronic module (CEM) with fuse
box B under the glovebox
50
Primary fuse for central electri-
cal unit in passenger compart-
ment with fuse box A under the
glovebox
60
Primary fuse for central electri-
cal unit in passenger compart-
ment with fuse box A under the
glovebox
60
Primary fuse for central electri-
cal unit in cargo area
60
Ventilation fan 40
- -
- -
Start relay 30
Internal diode 50
Function A
Support battery 70
Central electronic module
(CEM) - reference voltage sup-
port battery; Charging point
support battery
15

Related Topics

Wheels and tyres
General Changing wheels Tyre pressure Warning triangle and first-aid kit* Tyre pressure monitoring (TPMS)* Emergency puncture repair (TMK) Engine compartment Lamps Wiper blades and washer fluid Battery Car care

Popular Owner Manuals

Audi
Audi
BMW
BMW
Citroen
Citroen
Ford
Ford
Honda
Honda
Peugeot
Peugeot