Get Selective catalytic reduction (AdBlue?) -> Warning and indicator lights Guide for Volkswagen Passat SUV Sixth Generation (2005-2010)

Selective catalytic reduction (AdBlue^®)

ꢀIntroduction

In this section you’ll find information about:

Warning and indicator lights

AdBlue information

Refilling AdBlue

The fill level of AdBlue should be checked every time the vehicle is serviced ⇒ꢀbooklet Warranty and

Maintenance.

More information:

ꢀ

Luggage compartment

Fuel

Parts, accessories, repairs and modifications

WARNING

If the AdBlue fill level is too low, the vehicle cannot be restarted after the ignition was

switched off. It is also not possible to jump-start or emergency start the vehicle!

ꢀ

Refill AdBlue when the AdBlue fuel range falls to about 600 miles (1000 km).

Never let the AdBlue tank run dry.

WARNING

AdBlue is an irritating and corrosive fluid that can harm skin, eyes, mucous membranes, and

respiratory organs.

ꢀ

If AdBlue gets into the eyes, flush them thoroughly with large amounts of clean water for

at least 15 minutes; medical attention is recommended.

If AdBlue is swallowed, immediately rinse the mouth for at least 15 minutes with plenty of

ꢀ

water. Do not induce vomiting unless instructed to do so by a medical professional. Get

medical attention immediately.

NOTICE

ꢀ AdBlue corrodes surfaces such as painted vehicle components, plastics, clothing and

carpets. Remove spilled AdBlue immediately with a wet cloth and plenty of cold water.

ꢀ

Remove crystallized AdBlue with warm water and a sponge.

Warning and indicator lights

ꢀPlease first read and note the introductory information and heed the WARNINGS

Lights up

ꢀ

Proper response

Possible cause or meaning ⇒ꢀ

Stop the vehicle at a safe and appropriate

place with level pavement and refuel

AdBlue

No engine restart possible!

AdBlue fill level too low.

ꢀ

together

with

Have the system checked by an authorized

Volkswagen dealer or an authorized

Volkswagen Service Facility.

No engine restart possible!

AdBlue system malfunction.

ꢀ

Refill the AdBlue tank within the indicated

number of miles or kilometers. Volkswagen

recommends taking the vehicle to an

authorized Volkswagen dealer or an

authorized Volkswagen Service Facility.

AdBlue level is low.

ꢀ

together

with

Have the system checked by an authorized

Volkswagen dealer or an authorized

Volkswagen Service Facility.

AdBlue system malfunctioning or not

filled with standard AdBlue.

ꢀ

Refill the AdBlue tank within the indicated

number of miles or kilometers. Volkswagen

recommends taking the vehicle to an

authorized Volkswagen dealer or an

authorized Volkswagen Service Facility.

AdBlue level is low.

ꢀ

together

with

Have the system checked by an authorized

Volkswagen dealer or an authorized

Volkswagen Service Facility.

AdBlue system malfunctioning or not

filled with standard AdBlue.

ꢀ

When the ignition is switched on, several warning and indicator lights come on briefly for a function

check. They go out after a few seconds.

WARNING

Failure to heed warning lights and instrument cluster text messages can cause the vehicle to

break down in traffic and result in a collision and serious personal injury.

ꢀ

Never ignore warning lights or text WARNINGS.

Always stop the vehicle as soon as it is safe to do so.

NOTICE

Failure to heed warning lights or text WARNINGS can result in vehicle damage.

AdBlue information

ꢀPlease first read and note the introductory information and heed the WARNINGS

In vehicles with selective catalytic reduction, a special urea solution (AdBlue) is injected into the

exhaust system ahead of the catalytic converter in order to reduce nitrogen oxide emissions.

AdBlue is stored in a separate tank of the vehicle and should be refilled under normal driving

conditions during service according to the maintenance schedule. The AdBlue tank holds slightly less

than 5 gallons (about 18.5 liters).

AdBlue consumption depends on individual driving style, system operating temperature, and outside

air temperature. Therefore in rare cases AdBlue may have to be refilled between service events.

Starting with a remaining range of about 1500 miles (2400 km), a reminder to refill AdBlue is displayed

in the instrument cluster, Refilling AdBlue. If you ignore the last refill reminder, it is impossible to start

the engine again after it is switched off, Warning and indicator lights.

Volkswagen recommends that you have the AdBlue tank refilled by an authorized Volkswagen dealer

or an authorized Volkswagen Service Facility. If no authorized Volkswagen dealer or authorized

Volkswagen Service Facility or other qualified workshop is available, you should refill at least

1.5 gallons (5.7 liters) of AdBlue (3 AdBlue bottles). Refill only the type of AdBlue that Volkswagen has

explicitly approved for your vehicle.

If warning lights _~and _dboth come on together, there is a malfunction. Volkswagen recommends that

you take the vehicle to the closest qualified workshop.

AdBlue^®is a registered trademark of the German Association of the Automotive Industry (VDA) in the

United States, Germany, the European Union and in other countries.

Refilling AdBlue

Fig. 176 At the right rear of the luggage compartment: AdBlue tank underneath a cover.

Selective catalytic reduction (AdBlue?) -> Warning and indicator lights for Your Volkswagen Passat SUV Sixth Generation (2005-2010)

Related Topics

Selective catalytic reduction (AdBlue?)

Popular Owner Manuals

Latest Owner Manuals