Get Maintenance -> Scheduled maintenance service Guide for Kia Rio 4 Door Third Generation (2017-2023)

Maintenance

SCHEDULED MAINTENANCE SERVICE

Scheduled maintenance service precaution

Follow the Normal Maintenance Schedule if the vehicle is usually operated where none of the following conditions apply.

If any of the following conditions apply, follow the Maintenance Under Severe Usage Conditions.

• Repeated driving short distance of less than 5 miles (8 km) in normal temperature or less than 10 miles (16 km) in

freezing temperature

• Extensive engine idling or low speed driving for long distances

• Driving on rough, dusty, muddy, unpaved, graveled or salt-spread roads

• Driving in areas using salt or other corrosive materials or in very cold weather

• Driving in heavy dust condition

• Driving in heavy traffic area

• Driving on uphill, downhill, or mountain road repeatedly

• Towing a trailer or using a camper, or roof rack

• Driving as a patrol car, taxi, other commercial use of vehicle towing

• Driving over 106 mph (170 km/h)

• Frequently driving in stop-and-go condition

If your vehicle is operated under the above conditions, you should inspect, replace or refill more frequently than the

following Normal Maintenance Schedule. After 120 months or 150,000 miles continue to follow the prescribed main-

tenance intervals.

8 9

Maintenance

Normal Maintenance Schedule - Non Turbo Models

The following maintenance services must be performed to ensure good emission control and performance.

Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the

frequency of service is determined by whichever occurs first.

MAINTENANCE

INTERVALS

Number of months or driving distance, whichever comes first

Months

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

Miles×1,000

Km×1,000

7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90 97.5 105 112.5

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

MAINTENANCE

ITEM

At first, inspect at 60,000 miles (96,000 km) or 72 months,

after that, inspect every 15,000 miles (24,000 km) or 24 months

Drive belts *¹

Engine oil and engine oil Gamma II 1.6L

filter

R

I

R

I

R

I

R

I

MPI

Fuel additives *²

Air cleaner filter

Add every 7,500 miles (12,000 km) or 12 months

I

R

I

R

I

R

I

Gamma II 1.6L

MPI

Spark plugs

Rotate tires

Replace every 97,500 miles (156,000 km)

Rotate every 7,500 miles (12,000 km)

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*¹: The drive belt should be replaced when cracks occur or tension is reduced.

*²: If TOP TIER Detergent Gasoline is not available, one bottle of additive is recommended. Additives are available from your

authorized Kia dealer along with information on how to use them. Do not mix other additives.

8 10

Maintenance

Normal Maintenance Schedule - Non Turbo Models(CONT.)

MAINTENANCE

INTERVALS

Number of months or driving distance, whichever comes first

Months 12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

Miles×1,000 7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90 97.5 105 112.5

Km×1,000 12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

MAINTENANCE

ITEM

Climate control air filter

(for evaporator and blower unit)

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

R

I

Vacuum hose

At first, replace at 120,000 miles (192,000 km) or 10 years,

after that, replace every 30,000 miles (48,000 km) or 24 months

Coolant (Engine)

Battery condition

I

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

Brake lines, hoses and connections

Brake discs and pads

Steering gear rack, linkage and boots

Drive shaft and boots

Suspension ball joints and mounting

bolts

I

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

8 11

Maintenance

Normal Maintenance Schedule - Non Turbo Models (CONT.)

MAINTENANCE

INTERVALS

Number of months or driving distance, whichever comes first

Months

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

Miles×1,000

Km×1,000

7.5 15 22.5 30 37.5 45 52.5 60 67.5 75 82.5 90 97.5 105 112.5

12 24 36 48 60 72 84 96 108 120 132 144 156 168 180

MAINTENANCE

ITEM

Air conditioner compressor/refrigerant

Exhaust system

I

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

Cooling system

Intelligent variable transmission fluid

Manual transmission fluid *³

Vapor hose and fuel filler cap

Fuel tank air filter *⁴

No check, No service required

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

I

-

Fuel lines, hoses and connections

Parking brake

Brake/clutch (if equipped) fluid

I : Inspect and if necessary, adjust, correct, clean or replace.

R : Replace or change.

*³: Manual transmission fluid should be changed anytime it has been submerged in water.

*⁴: Fuel tank air filter is considered to be maintenance free but periodic inspection is recommended as the level of maintenance

will be dependent upon the quality fuel used in the vehicle.

8 12

Maintenance

Maintenance Under Severe Usage Conditions - Non Turbo Models

The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer

to the chart below for the appropriate maintenance intervals.

R : Replace

I : Inspect and, after inspection, clean, adjust, repair or replace if necessary

MAINTENANCE

OPERATION

DRIVING

CONDITION

MAINTENANCE ITEM

MAINTENANCE INTERVALS

Engine oil and

Every 3,750 miles (6,000 km)

or 6 months

A, B, C, D, E,

F, G, H, I, J, K

Gamma II 1.6L MPI

R

engine oil filter

Air cleaner filter

Spark plugs

R

More frequently

C, E

A, B, F, G, H, I, K

A, C, D, E,

F, G, H, I, J

Intelligent variable transmission fluid

Manual transmission fluid

Every 60,000 miles (96,000 km)

Every 75,000 miles (120,000 km)

R

C, D, E, F,

G, H, I, J

Brake discs and pads, calipers and rotors

Parking brake

I

More frequently

C, D, E, G, H

C, D, G, H

Steering gear rack, linkage and boots

Suspension ball joints and mounting bolts

C, D, E, F, G

8 13

Maintenance

MAINTENANCE

OPERATION

DRIVING

CONDITION

MAINTENANCE ITEM

MAINTENANCE INTERVALS

More frequently

C, D, E, F,

G, H, I, J

Drive shafts and boots

I

Climate control air filter

(for evaporator and blower unit)

More frequently

C, E, G

R

Severe driving conditions

E-Driving in heavy dust condition

F -Driving in heavy traffic area

A-Repeatedly driving short distance of less than 5 miles (8 km)

in normal temperature or less than 10 miles (16 km) in freez-

ing temperature

G-Driving on uphill, downhill, or mountain road repeatedly

H-Towing a Trailer, or using a camper, or roof rack

B-Extensive engine idling or low speed driving for long dis-

tances

I -Driving as a patrol car, taxi, other commercial use or vehicle

towing

C-Driving on rough, dusty, muddy, unpaved, graveled or salt-

spread roads

J -Driving over 106 mph (170 km/h)

D-Driving in areas using salt or other corrosive materials or in

very cold weather

K-Frequently driving in stop-and-go conditions

8 14

Maintenance -> Scheduled maintenance service for Your Kia Rio 4 Door Third Generation (2017-2023)

Related Topics

Popular Owner Manuals

Latest Owner Manuals