2016-2024 Suzuki Ignis SUV Inspection and Maintenance -> Maintenance recommended under severe driving conditions (for EU countries and Israel) User Manual
MyCarUserManual.com
USER MANUALS FOR EVERY MAKE & MODEL

Inspection and Maintenance -> Maintenance recommended under severe driving conditions (for EU countries and Israel) for Your Suzuki Ignis SUV Second Generation (2016-2024)

7-18
INSPECTION AND MAINTENANCE
75RM4-01E
Maintenance recommended under severe driving conditions (for EU countries and Israel)
Follow this schedule if your vehicle is mainly operated under one or more of the following conditions:
• When most trips are less than 6 km (4 miles).
• When most trips are less than 16 km (10 miles) and outside temperature remains below freezing.
• Idling and/or low-speed operation in stop-and-go traffic.
• Operating in extremely cold weather and/or on salted roads.
• Operating in rough and/or muddy areas.
• Operating in dusty areas.
• Repeated high speed drive or high engine revolutions.
• Towing a trailer, if admitted.
Schedule should also be followed if the vehicle is used for delivery service, police, taxi or other commercial applications.
7-19
INSPECTION AND MAINTENANCE
75RM4-01E
#1: For further details, see “Engine oil and filter” in this section.
#2: Perform the engine coolant level check under the daily inspection in the “OPERATING YOUR VEHICLE” section.
If you use the engine coolant other than “SUZUKI LLC: Super (Blue)” for replacement, follow the schedule of “SUZUKI LLC: Standard (Green)”.
Interval: This interval should be judged by
odometer reading or months, whichever comes
first.
km (x1000) 10 20 30 40 50 60
miles (x1000) 6.25 12.5 18.75 25 31.25 37.5
months6 1218243036
ENGINE
*1-1. Engine accessory drive belt Tension check, *Adjustment, *Replacement – I – I – R
1-2. Engine oil and engine oil filter ACEA Standards or SUZUKI GENUINE OIL (#1) R R R R R R
Refer to “Oil change request light” in the “BEFORE DRIVING” section.
Other than ACEA Standards or SUZUKI GENUINE OIL (#1) Replace every 7500 km (4687 miles) or 6 months.
Refer to “Oil change request light” in the “BEFORE DRIVING” section.
1-3. Engine coolant SUZUKI LLC: Super (Blue) (#2) First time only: Replace at 160000 km (100000 miles) or 96 months.
Second time and after: Replace every 80000 km (50000 miles) or 48 months.
SUZUKI LLC: Standard (Green) Replace every 40000 km (25000 miles) or 36 months.
*1-4. Exhaust system (except catalyst) ––– I ––
IGNITION
2-1. Spark plugs Iridium plug Replace every 30000 km (18750 miles) or 24 months.
FUEL
3-1. Air cleaner filter element*
1
Inspect every 2500 km (1562 miles).
Replace every 30000 km (18750 miles) or 24 months.
*3-2. Fuel lines ––– I ––
*3-3. Fuel tank – – – I – –
EMISSION CONTROL SYSTEM
*4-1. PCV valve Inspect every 80000 km (50000 miles) or 48 months.
*4-2.
Fuel evaporative emission control system
––––––
7-20
INSPECTION AND MAINTENANCE
75RM4-01E
#1: For further details, see “Engine oil and filter” in this section.
#2: Perform the engine coolant level check under the daily inspection in the “OPERATING YOUR VEHICLE” section.
If you use the engine coolant other than “SUZUKI LLC: Super (Blue)” for replacement, follow the schedule of “SUZUKI LLC: Standard (Green)”.
Interval: This interval should be judged by
odometer reading or months, whichever comes
first.
km (x1000) 70 80 90 100 110 120
miles (x1000) 43.75 50 56.25 62.5 68.75 75
months 42 48 54 60 66 72
ENGINE
*1-1. Engine accessory drive belt Tension check, *Adjustment, *Replacement – I – I – R
1-2. Engine oil and engine oil filter ACEA Standards or SUZUKI GENUINE OIL (#1) R R R R R R
Refer to “Oil change request light” in the “BEFORE DRIVING” section.
Other than ACEA Standards or SUZUKI GENUINE OIL (#1) Replace every 7500 km (4687 miles) or 6 months.
Refer to “Oil change request light” in the “BEFORE DRIVING” section.
1-3. Engine coolant SUZUKI LLC: Super (Blue) (#2) First time only: Replace at 160000 km (100000 miles) or 96 months.
Second time and after: Replace every 80000 km (50000 miles) or 48 months.
SUZUKI LLC: Standard (Green) Replace every 40000 km (25000 miles) or 36 months.
*1-4. Exhaust system (except catalyst) – I ––– I
IGNITION
2-1. Spark plugs Iridium plug Replace every 30000 km (18750 miles) or 24 months.
FUEL
3-1. Air cleaner filter element*
1
Inspect every 2500 km (1562 miles).
Replace every 30000 km (18750 miles) or 24 months.
*3-2. Fuel lines – I ––– I
*3-3. Fuel tank – I – – – I
EMISSION CONTROL SYSTEM
*4-1. PCV valve Inspect every 80000 km (50000 miles) or 48 months.
*4-2.
Fuel evaporative emission control system
––––– I
7-21
INSPECTION AND MAINTENANCE
75RM4-01E
Interval: This interval should be judged by
odometer reading or months, whichever
comes first.
km (x1000) 10 20 30 40 50 60
miles (x1000) 6.25 12.5 18.75 25 31.25 37.5
months6 1218243036
BRAKE
*5-1. Brake discs and pads (front) –I–I–I
Brake drums and shoes (rear) – – – I – –
*5-2. Brake hoses and pipes ––– I ––
5-3. Brake fluid Check, *Replacement – – – R – –
5-4. Brake lever and cable
Check, *Adjustment (1st 20000 km only)
– I ––––
CHASSIS AND BODY
*6-1. Clutch (Cable control type) –I–I–I
6-2. Tires/Wheels – I – I – I
*6-3. Wheel bearings –I–I–I
*6-4. Drive axle boots/Propeller shafts (4WD) – – – I – –
*6-5. Suspension system ––– I ––
*6-6. Steering system – – – I – –
*6-7.
Manual transaxle oil Genuine “SUZUKI GEAR OIL 75W”
Inspect every 20000 km (12500 miles) or 12 months.
Replace every 80000 km (50000 miles) or 48 months.
Other than “SUZUKI GEAR OIL 75W”
–R–R–R
*6-8. Auto Gear Shift oil Genuine “SUZUKI GEAR OIL 75W” Inspect every 20000 km (12500 miles) or 12 months.
Replace every 80000 km (50000 miles) or 48 months.
Other than “SUZUKI GEAR OIL 75W” – R – R – R
6-9. Continuously variable transaxle (CVT) Fluid level – I – I – I
*Fluid deterioration check*
2
– I – I – I
*Fluid change Replace every 70000 km (43750 miles).
*6-10. Transfer oil (4WD) Inspect every 20000 km (12500 miles) or 12 months.
Replace every 80000 km (50000 miles) or 48 months.
*6-11. Rear differential oil (4WD) Inspect every 20000 km (12500 miles) or 12 months.
Replace every 80000 km (50000 miles) or 48 months.
6-12. All latches, hinges and locks – – – I – –
*6-13. Air conditioner filter element (if equipped)*
3
–I–I–R
WARNING
The shock absorbers are filled with high pressure gas. Never attempt to disassemble them or throw them into a fire. Avoid
storing them near a heater or heating device. When scrapping the absorber, the gas must be released from the absorber
safely. Ask your dealer for assistance.
7-22
INSPECTION AND MAINTENANCE
75RM4-01E
NOTE:
4WD: 4-wheel drive
NOTE:
This table shows the service schedule up to 120000 km (75000 miles).
Beyond 120000 km (75000 miles), perform the same services at the same intervals shown in the chart.
*1 Inspect more frequently if the vehicle is used under dusty conditions.
*2 Check or replace as necessary if you usually drive with high speed or high engine revolutions.
*3 Clean more frequently if the air flow from the air conditioner decreases.
Interval: This interval should be judged by
odometer reading or months, whichever
comes first.
km (x1000) 70 80 90 100 110 120
miles (x1000) 43.75 50 56.25 62.5 68.75 75
months 42 48 54 60 66 72
BRAKE
*5-1. Brake discs and pads (front) –I–I–I
Brake drums and shoes (rear) – I – – – I
*5-2. Brake hoses and pipes –I–––I
5-3. Brake fluid Check, *Replacement – R – – – R
5-4. Brake lever and cable
Check, *Adjustment (1st 20000 km only)
––––––
CHASSIS AND BODY
*6-1. Clutch (Cable control type) –I–I–I
6-2. Tires/Wheels – I – I – I
*6-3. Wheel bearings –I–I–I
*6-4. Drive axle boots/Propeller shafts (4WD) – I – – – I
*6-5. Suspension system –I–––I
*6-6. Steering system – I – – – I
*6-7.
Manual transaxle oil Genuine “SUZUKI GEAR OIL 75W”
Inspect every 20000 km (12500 miles) or 12 months.
Replace every 80000 km (50000 miles) or 48 months.
Other than “SUZUKI GEAR OIL 75W”
–R–R–R
*6-8. Auto Gear Shift oil Genuine “SUZUKI GEAR OIL 75W” Inspect every 20000 km (12500 miles) or 12 months.
Replace every 80000 km (50000 miles) or 48 months.
Other than “SUZUKI GEAR OIL 75W” – R – R – R
6-9. Continuously variable transaxle (CVT) Fluid level – I – I – I
*Fluid deterioration check*
2
– I – I – I
*Fluid change Replace every 70000 km (43750 miles).
*6-10. Transfer oil (4WD) Inspect every 20000 km (12500 miles) or 12 months.
Replace every 80000 km (50000 miles) or 48 months.
*6-11. Rear differential oil (4WD) Inspect every 20000 km (12500 miles) or 12 months.
Replace every 80000 km (50000 miles) or 48 months.
6-12. All latches, hinges and locks – I – – – I
*6-13. Air conditioner filter element (if equipped)*
3
–I–I–R

Related Topics

Inspection and Maintenance
Maintenance schedule Periodic maintenance schedule (except for EU countries and Israel) Maintenance recommended under severe driving conditions (except for EU countries and Israel) Periodic maintenance schedule (for EU countries and Israel) Drive belt Engine oil and filter Engine coolant Air cleaner Spark plugs Continuously variable transaxle (CVT) fluid Gear oil Clutch pedal Brakes Steering Tires Battery Fuses Headlight aiming Bulb replacement Wiper blades Windshield washer fluid Air conditioning system

Popular Owner Manuals

Audi
Audi
BMW
BMW
Citroen
Citroen
Ford
Ford
Honda
Honda
Peugeot
Peugeot