2016-2024 Suzuki Ignis SUV Inspection and Maintenance -> Periodic maintenance schedule (except for EU countries and Israel) User Manual
MyCarUserManual.com
USER MANUALS FOR EVERY MAKE & MODEL

Inspection and Maintenance -> Periodic maintenance schedule (except for EU countries and Israel) for Your Suzuki Ignis SUV Second Generation (2016-2024)

7-3
INSPECTION AND MAINTENANCE
75RM4-01E
Periodic maintenance schedule (except for EU countries and Israel)
“R” : Replace or Change
“I” : Inspect, clean, adjust, lubricate or replace as necessary
NOTE:
• Class 1: K12C engine
• Class 2: K12M engine
NOTE:
This table shows the service schedule up to 180000 km (108000 miles). Beyond 180000 km (108000 miles), perform the same services
at the same intervals shown in the chart.
7-4
INSPECTION AND MAINTENANCE
75RM4-01E
• Class 1: K12C engine
• Class 2: K12M engine
• For Item 2-1. “Nickel plugs”, replace every 50000 km
if the local law requires.
#1: Valve clearance for K12C engine models is not required for maintenance.
#2: Perform the engine coolant level check under the daily inspection in the “OPERATING YOUR VEHICLE” section.
If you use the engine coolant other than “SUZUKI LLC: Super (Blue)” for replacement, follow the schedule of “SUZUKI LLC: Stan-
dard (Green)”.
Interval: This interval should be judged by
odometer reading or months, whichever comes
first.
km (x1000) 15 30 45 60 75 90
miles (x1000) 9 18 27 36 45 54
months 12 24 36 48 60 72
ENGINE
*1-1. Engine accessory drive belt [Class 1] Tension check, *Adjustment, *Replacement – – I – – R
[Class 2] Tension check, *Adjustment, *Replacement – – I – – R
*1-2. Valve clearance [Class 2] (#1) – I – I – I
1-3. Engine oil and engine oil filter R R R R R R
1-4. Engine coolant SUZUKI LLC: Super (Blue) (#2) First time only: Replace at 150000 km (90000 miles) or 96 months.
Second time and after: Replace every 75000 km (45000 miles) or 48 months.
SUZUKI LLC: Standard (Green) – – R – – R
*1-5. Exhaust system (except catalyst) – I – I – I
IGNITION
2-1. Spark plugs When unleaded fuel is used [Class 1] Iridium plug Replace every 105000 km (63000 miles) or 84 months.
[Class 2] Nickel plug – – R – – R
Spark plugs When leaded fuel is used, refer to “Severe driving condition” schedule.
FUEL
3-1. Air cleaner filter element Paved-road I I R I I R
Dusty condition Refer to “Severe driving condition” schedule.
*3-2. Fuel lines – I – I – I
*3-3. Fuel filter Replace every 105000 km (63000 miles).
*3-4. Fuel tank – – I – – I
EMISSION CONTROL SYSTEM
*4-1. PCV valve Inspect every 80000 km (50000 miles) or 48 months.
*4-2.
Fuel evaporative emission control system
––––– I
7-5
INSPECTION AND MAINTENANCE
75RM4-01E
#1: Valve clearance for K12C engine models is not required for maintenance.
#2: Perform the engine coolant level check under the daily inspection in the “OPERATING YOUR VEHICLE” section.
If you use the engine coolant other than “SUZUKI LLC: Super (Blue)” for replacement, follow the schedule of “SUZUKI LLC: Stan-
dard (Green)”.
Interval: This interval should be judged by
odometer reading or months, whichever comes
first.
km (x1000) 105 120 135 150 165 180
miles (x1000) 63 72 81 90 99 108
months 84 96 108 120 132 144
ENGINE
*1-1. Engine accessory drive belt [Class 1] Tension check, *Adjustment, *Replacement – – I – – R
[Class 2] Tension check, *Adjustment, *Replacement – – I – – R
*1-2. Valve clearance [Class 2] (#1) – I – I – I
1-3. Engine oil and engine oil filter R R R R R R
1-4. Engine coolant SUZUKI LLC: Super (Blue) (#2) First time only: Replace at 150000 km (90000 miles) or 96 months.
Second time and after: Replace every 75000 km (45000 miles) or 48 months.
SUZUKI LLC: Standard (Green) – – R – – R
*1-5. Exhaust system (except catalyst) – I – I – I
IGNITION
2-1. Spark plugs When unleaded fuel is used [Class 1] Iridium plug Replace every 105000 km (63000 miles) or 84 months.
[Class 2] Nickel plug – – R – – R
Spark plugs When leaded fuel is used, refer to “Severe driving condition” schedule.
FUEL
3-1. Air cleaner filter element Paved-road I I R I I R
Dusty condition Refer to “Severe driving condition” schedule.
*3-2. Fuel lines – I – I – I
*3-3. Fuel filter Replace every 105000 km (63000 miles).
*3-4. Fuel tank – – I – – I
EMISSION CONTROL SYSTEM
*4-1. PCV valve Inspect every 80000 km (50000 miles) or 48 months.
*4-2.
Fuel evaporative emission control system
––––– I
7-6
INSPECTION AND MAINTENANCE
75RM4-01E
#3: Tires/Wheels (including tire rotation) for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
#4: Wheel bearings for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
#5: Drive axle boots for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
#6: Suspension system for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
#7: Steering system for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
Interval: This interval should be judged by
odometer reading or months, whichever
comes first.
km (x1000) 15 30 45 60 75 90
miles (x1000) 9 18 27 36 45 54
months 12 24 36 48 60 72
BRAKE
*5-1. Brake discs and pads (front) IIIIII
Brake drums and shoes (rear) – I – I – I
*5-2. Brake hoses and pipes –I–I–I
5-3. Brake fluid Check, *Replacement – R – R – R
5-4. Brake lever and cable
Check, *Adjustment (1st 15000 km only)
I –––––
CHASSIS AND BODY
*6-1. Clutch (Cable control type) IIIIII
6-2. Tires/Wheels (#3) I I I I I I
*6-3. Wheel bearings (#4) –I–I–I
*6-4. Drive axle boots (#5) – – I – – I
*6-5. Suspension system (#6) –I–I–I
*6-6. Steering system (#7) – I – I – I
*6-7.
Manual transaxle oil Genuine “SUZUKI GEAR OIL 75W”
Inspect every 30000 km (18000 miles) or 24 months.
Other than “SUZUKI GEAR OIL 75W”
(I: 1st 15000 km only) I – R – – R
6-8. Continuously variable transaxle (CVT) Fluid level – I – I – I
6-9. All latches, hinges and locks – I – I – I
*6-10. Air conditioner filter element (if equipped) –IR–IR
WARNING
The shock absorbers are filled with high pressure gas. Never attempt to disassemble them or throw them into a fire. Avoid
storing them near a heater or heating device. When scrapping the absorber, the gas must be released from the absorber
safely. Ask your dealer for assistance.
7-7
INSPECTION AND MAINTENANCE
75RM4-01E
#3: Tires/Wheels (including tire rotation) for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
#4: Wheel bearings for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
#5: Drive axle boots for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
#6: Suspension system for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
#7: Steering system for Mexico models :Inspect every 15000 km (9000 miles) or 12 months.
Interval: This interval should be judged by
odometer reading or months, whichever
comes first.
km (x1000) 105 120 135 150 165 180
miles (x1000) 63 72 81 90 99 108
months 84 96 108 120 132 144
BRAKE
*5-1. Brake discs and pads (front) IIIIII
Brake drums and shoes (rear) – I – I – I
*5-2. Brake hoses and pipes –I–I–I
5-3. Brake fluid Check, *Replacement – R – R – R
5-4. Brake lever and cable
Check, *Adjustment (1st 15000 km only)
––––––
CHASSIS AND BODY
*6-1. Clutch (Cable control type) IIIIII
6-2. Tires/Wheels (#3) I I I I I I
*6-3. Wheel bearings (#4) –I–I–I
*6-4. Drive axle boots (#5) – – I – – I
*6-5. Suspension system (#6) –I–I–I
*6-6. Steering system (#7) – I – I – I
*6-7.
Manual transaxle oil Genuine “SUZUKI GEAR OIL 75W”
Inspect every 30000 km (18000 miles) or 24 months.
Other than “SUZUKI GEAR OIL 75W”
(I: 1st 15000 km only) – – R – – R
6-8. Continuously variable transaxle (CVT) Fluid level – I – I – I
6-9. All latches, hinges and locks – I – I – I
*6-10. Air conditioner filter element (if equipped) –IR–IR

Related Topics

Inspection and Maintenance
Maintenance schedule Maintenance recommended under severe driving conditions (except for EU countries and Israel) Periodic maintenance schedule (for EU countries and Israel) Maintenance recommended under severe driving conditions (for EU countries and Israel) Drive belt Engine oil and filter Engine coolant Air cleaner Spark plugs Continuously variable transaxle (CVT) fluid Gear oil Clutch pedal Brakes Steering Tires Battery Fuses Headlight aiming Bulb replacement Wiper blades Windshield washer fluid Air conditioning system

Popular Owner Manuals

Audi
Audi
BMW
BMW
Citroen
Citroen
Ford
Ford
Honda
Honda
Peugeot
Peugeot