Get Inspection and Maintenance -> Engine Coolant Guide for Suzuki S Cross SUV First Generation (2006-2012)

7-14

INSPECTION AND MAINTENANCE

80J23-03E

NOTE:

When it is difficult to remove the oil filter,

we recommend you take your vehicle to

your SUZUKI dealer for oil filter replace-

ment.

Refill with Oil and Check for Leaks

1) Pour oil through the filler hole and

install the filler cap.

For the approximate capacity of the oil,

refer to the “Capacities” item in the

“SPECIFICATIONS” section.

2) Start the engine and look carefully for

leaks at the oil filter and drain plug. Run

the engine at various speeds for at least

5 minutes.

3) Stop the engine and wait about 5 min-

utes. Check the oil level again and add

oil if necessary. Check for leaks again.

80J014

Engine Coolant

Selection of Coolant

To maintain optimum performance and

durability of your engine, use SUZUKI

Genuine Coolant or equivalent.

NOTE:

If you replace the engine coolant other

than the SUZUKI LLC: Super (Blue), follow

the schedule of SUZUKI LLC: Standard

(Green). To see the detail of the mainte-

nance schedule, refer to “Periodic Mainte-

nance Schedule” in this section.

This type of coolant is best for your cooling

system as it:

• Helps maintain proper engine tempera-

ture.

• Gives proper protection against freezing

and boiling.

• Gives proper protection against corro-

sion and rust.

CAUTION

When replacing the oil filter, it is rec-

ommended that you use a genuine

SUZUKI replacement filter. If you use

an after-market filter, make sure it is

of equivalent quality and carefully fol-

low the manufacturer’s instructions

and precautions.

CAUTION

Oil leaks from around the oil filter or

drain plug indicate incorrect installa-

tion or gasket damage. If you find any

leaks or are not sure that the filter

has been properly tightened, have

the vehicle inspected by your SUZUKI

dealer.

EXAMPLE

CAUTION

SUZUKI LLC: Super (Blue) coolant;

SUZUKI LLC: Super (Blue) coolant is

already diluted to the proper percent-

age. Do not dilute with distilled water

additionally. Doing so may result in

the possibility of freezing coolant

and/or overheating.

7-15

INSPECTION AND MAINTENANCE

80J23-03E

Failure to use the proper coolant can dam-

age your cooling system. Your authorized

SUZUKI dealer can help you select the

proper coolant.

Coolant Level Check

Check the engine coolant level at the

reserve tank, not at the radiator. With the

engine cool, the engine coolant level

should be between the “FULL” and “LOW”

marks.

Adding Coolant

56KN090

If the engine coolant level is below the

“LOW” mark, more engine coolant should

be added. Remove the reserve tank cap

and add engine coolant until the reserve

tank level reaches the “FULL” mark. Never

fill the reserve tank above the “FULL” mark.

CAUTION

To avoid damaging your cooling sys-

tem:

• Always use a high quality ethylene

glycol base phosphate type coolant

diluted with distilled water at the

correct mixture concentration.

• Make sure that the proper mix is 50/

50 coolant to distilled water and in

no case higher than 70/30. Concen-

trations greater than 70/30 coolant

to distilled water will cause over-

heating conditions.

• Do not use straight coolant nor

plain water (except SUZUKI LLC:

Super (Blue)).

• Do not add extra inhibitors or addi-

tives. They may not be compatible

with your cooling system.

• Do not mix different types of base

coolants. Doing so may result in

accelerated seal wear and/or the

possibility of severe overheating

and extensive engine/CVT damage.

WARNING

Engine coolant is harmful or fatal if

swallowed or inhaled. Do not drink

antifreeze or coolant solution. If swal-

lowed, do not induce vomiting. Imme-

diately contact a poison control

center or a physician. Avoid inhaling

mist or hot vapors; if inhaled, remove

to fresh air. If coolant gets in eyes,

flush eyes with water and seek medi-

cal attention. Wash thoroughly after

handling. Solution can be poisonous

to animals. Keep out of the reach of

children and animals.

CAUTION

SUZUKI LLC: Super (Blue) coolant;

SUZUKI LLC: Super (Blue) coolant is

already diluted to the proper percent-

age. Do not dilute with distilled water

additionally. Doing so may result in

the possibility of freezing coolant

and/or overheating.

7-16

INSPECTION AND MAINTENANCE

80J23-03E

Coolant Replacement

Since special procedures are required, we

recommend you take your vehicle to your

SUZUKI dealer for coolant replacement.

Air Cleaner

80J2056

If the air cleaner is clogged with dust, there

will be greater intake resistance, resulting

in decreased power output and increased

fuel consumption.

Unclamp the side clamps, and remove the

element from the air cleaner case. If it

appears to be dirty, replace it with a new

one.

Spark Plugs

You should inspect spark plugs periodically

for carbon deposits. When carbon accu-

mulates on a spark plug, a strong spark

may not be produced. Remove carbon

deposits with a wire or pin and adjust the

spark plug gap.

To access the spark plugs,

80J2069

1) Remove the air cleaner inlet hose (1).

Remove the front part (2), then remove

the rear part (3) of the air cleaner case.

CAUTION

SUZUKI LLC: Standard (Green)

coolant;

• The mixture you use should con-

tain 50% concentration of anti-

freeze.

• If the lowest ambient temperature

in your area is expected to be

–35°C (–31°F) or below, use higher

concentrations up to 60% following

the instructions on the antifreeze

container.

CAUTION

When putting the cap on the reser-

voir tank, line up the mark on the cap

and the mark on the tank. Failure to

follow this can result in coolant leak-

age.

CAUTION

The air cleaner element should be

replaced every 50000 km (30000

miles). More frequent replacement is

necessary when you drive under

dusty conditions.

CAUTION

When remove the engine cover, make

sure the cover does not interfere the

vehicle to avoid damage to the cover.

(1)

(2)

(3)

Inspection and Maintenance -> Engine Coolant for Your Suzuki S Cross SUV First Generation (2006-2012)

Related Topics

Popular Owner Manuals

Latest Owner Manuals