Get Inspection and Maintenance -> Maintenance Recommended under Severe Driving Conditions Guide for Suzuki S Cross SUV First Generation (2006-2012)

7-7

INSPECTION AND MAINTENANCE

80J23-03E

Maintenance Recommended under Severe Driving Conditions

Follow this schedule if your car is mainly operated under one or more of the following conditions:

• When most trips are less than 6 kilometers (4 miles)

• When most trips are less than 16 kilometers (10 miles) and outside temperature remain below freezing.

• Idling and/or low-speed operation in stop-and-go traffic.

• Operating in dusty areas.

Schedule should also be followed if the car is used for delivery service, police, taxi or other commercial applications.

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

#1: Be sure to perform the engine coolant level check under the daily inspection in “OPERATING YOUR VEHICLE” section.

If you replace the engine coolant other than the SUZUKI LLC: Super (Blue), follow the schedule of SUZUKI LLC: Standard (Green).

Interval: This interval should be judged by

odometer reading or months, whichever

comes first.

miles (x 1000) 3 6 9 12151821242730333639

km (x 1000) 5 10 15 20 25 30 35 40 45 50 55 60 65

months 3 6 9 12151821242730333639

ENGINE & EMISSION CONTROL

1. Drive belt

Inspect for damage – – – – – – – – – I – – –

*2.Valve lash (clearance) –––––––––––––

3. Engine oil and oil filter R R R R R R R R R R R R R

*4. Cooling system hoses and connections – – – – I – – – – I – – –

5. Engine coolant SUZUKI LLC: Standard (Green) – – – – – – – – – R – – –

SUZUKI LLC: Super (Blue) (#1) First time only: Replace at 150000 km (90000 miles) or 90 months

Second time and after: Replace every 75000 km (45000 miles) or 45 months

*6. Exhaust pipes and mountings – – – – I – – – – I – – –

*7. EVAP canister Replace every 250000 km (150000 miles) or 180 months

*8. Emission-related hoses & tubes – – –––––––––––

9. Spark plugs – – – – – – – – – – – – –

*10.Ignition coil (plug cap) ––––––––– I –––

*11. Fuel tank & cap – – – – I – – – – I – – –

12. Air cleaner filter element (paved road) I I IIIIIIIRIII

*13. Fuel filter Replace every 250000 km (150000 miles) or 150 months

*14. Fuel lines and connections – – – – I – – – – I – – –

*15. Canister air suction filter – – – – – – – – – – – – –

7-8

INSPECTION AND MAINTENANCE

80J23-03E

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

#1: Be sure to perform the engine coolant level check under the daily inspection in “OPERATING YOUR VEHICLE” section.

If you replace the engine coolant other than the SUZUKI LLC: Super (Blue), follow the schedule of SUZUKI LLC: Standard (Green).

Interval: This interval should be judged by

odometer reading or months, whichever

comes first.

miles (x 1000) 42 45 48 51 54 57 60 63 66 69 72 75

km (x 1000) 70 75 80 85 90 95 100 105 110 115 120 125

months 42 45 48 51 54 57 60 63 66 69 72 75

ENGINE & EMISSION CONTROL

1. Drive belt

Inspect for damage – – – – – – I – – – – –

*2. Valve lash (clearance) – – – – – – I – – – – –

3. Engine oil and oil filter R R R R R R R R R R R R

*4. Cooling system hoses and connections – I – – – – I – – – – I

5. Engine coolant SUZUKI LLC: Standard (Green) – – – – – – R – – – – –

SUZUKI LLC: Super (Blue) (#1) First time only: Replace at 150000 km (90000 miles) or 90 months

Second time and after: Replace every 75000 km (45000 miles) or 45 months

*6. Exhaust pipes and mountings – I – – – – I – – – – I

*7. EVAP canister Replace every 250000 km (150000 miles) or 180 months

*8. Emission-related hoses & tubes – – – – – – I – – – – –

9. Spark plugs – – – – – – R – – – – –

*10. Ignition coil (plug cap) – – – – – – I – – – – –

*11. Fuel tank & cap – I – – – – I – – – – I

12. Air cleaner filter element (paved road) I I I I I I R I I I I I

*13. Fuel filter Replace every 250000 km (150000 miles) or 150 months

*14. Fuel lines and connections – I – – – – I – – – – I

*15. Canister air suction filter – – – – – – – – – – – R

7-9

INSPECTION AND MAINTENANCE

80J23-03E

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

Interval: This interval should be judged by odometer

reading or months, whichever comes first.

miles (x 1000) 3 6 9 12 15 18 21 24 27 30 33 36 39

km (x 1000) 5 101520253035404550556065

months 3 6 9 12151821242730333639

CHASSIS AND BODY

1. Clutch (for manual transaxle)

Pedal and fluid level – – – – I – – – – I – – –

*2. Brake discs and pads (front, rear) – I – I – – – I – – – I –

Brake drums and shoes (rear) – I – I – – – I – – – I –

*3. Brake hoses and pipes – I – I – – – I – – – I –

4. Brake fluid level check, *replacement – – – – I – – – – I – – –

5. Brake pedal stroke check, *adjustment – – – – I – – – – I – – –

6. Parking brake lever and *cable

Lever movement check, *adjustment – I – – I – – – – I – – –

7. Tires (including tire rotation) – I – I – I – I – I – I –

8. Wheel discs – I – I – I – I – I – I –

*9. Wheel bearings – – – I – – – I – – – I –

*10. Suspension system – I – I – I – I – I – I –

*11. Propeller shafts (i-AWD)/Drive axle boots – I – I – I – I – I – I –

*12. Manual transaxle oil

Level check, *replacement – – – – I – – – – I – – –

13. Continuously variable transaxle (CVT) Fluid level – – – – I – – – – I – – –

*Fluid deterioration check*

– – – – I – – – – I – – –

*Fluid hose –––––––––––––

*14. Transfer oil (i-AWD) – – – – R – – – – R – – –

*15. Rear differential oil (i-AWD) – – – – R – – – – R – – –

16. Steering system

Steering wheel movement, *linkage – I – I – I – I – I – I –

17. Power steering (if equipped) – I – I – I – I – I – I –

18. All latches, hinges and locks – I – I – I – I – I – I –

19. Air conditioner filter element (if equipped)*

– I – I – I – I – R – I –

7-10

INSPECTION AND MAINTENANCE

80J23-03E

R: Replace or change

I : Inspect, clean, adjust, lubricate or replace as necessary

NOTE:

This table shows the service schedule up to 125000 km (75000 miles).

Beyond 125000 km (75000 miles), perform the same services at the same intervals shown in the chart.

Clean more frequently if the air flow from the air conditioner decreases.

Check or replace as necessary if you usually drive with high speed or high engine revolutions.

Interval: This interval should be judged by odometer

reading or months, whichever comes first.

miles (x 1000) 42 45 48 51 54 57 60 63 66 69 72 75

km (x 1000) 70 75 80 85 90 95 100 105 110 115 120 125

months 42 45 48 51 54 57 60 63 66 69 72 75

CHASSIS AND BODY

1. Clutch (for manual transaxle)

Pedal and fluid level – I – – – – I – – – – I

*2. Brake discs and pads (front, rear) – – I – – – I – – – I –

Brake drums and shoes (rear) – – I – – – I – – – I –

*3. Brake hoses and pipes – – I – – – I – – – I –

4. Brake fluid level check, *replacement – I – – – – R – – – – I

5.Brake pedal stroke check, *adjustment – I ––––I –––– I

6. Parking brake lever and *cable

Lever movement check, *adjustment – I –––– I –––– I

7. Tires (including tire rotation) I – I – I – I – I – I –

8.Wheel discs I–I–I–I–I–I–

*9. Wheel bearings – – I – – – I – – – I –

*10. Suspension system I – I – I – I – I – I –

*11. Propeller shafts (i-AWD)/Drive axle boots I – I – I – I – I – I –

*12. Manual transaxle oil

Level check, *replacement – R – – – – I – – – – I

13. Continuously variable transaxle (CVT) Fluid level – I ––––I –––– I

*Fluid deterioration check*

– I – – – – I – – – – I

*Fluid hose – I ––––––––––

*14. Transfer oil (i-AWD) – R – – – – R – – – – R

*15.Rear differential oil (i-AWD) –R––––R––––R

16. Steering system

Steering wheel movement, *linkage I – I – I – I – I – I –

17. Power steering (if equipped) I – I – I – I – I – I –

18. All latches, hinges and locks I – I – I – I – I – I –

19. Air conditioner filter element (if equipped)*

I – I – I – R – I – I –

Inspection and Maintenance -> Maintenance Recommended under Severe Driving Conditions for Your Suzuki S Cross SUV First Generation (2006-2012)

Related Topics

Popular Owner Manuals

Latest Owner Manuals