5
VEHICLE MAINTENANCE REQUIREMENTS
7
F040A02JM-GAT
The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer to the
chart below for the appropriate maintenance intervals.
R : Replace I : Inspect and, after inspection, clean, adjust, repair or replace if necessary
SEVERE DRIVING CONDITIONS
A - Repeatly driving short distance of less than 8km(5miles) in normal tempera
ture or less than 16km(10miles) in freezing temperature
B - Extensive engine idling or low speed driving for long distances
C - Driving on rough, dusty, muddy, unpaved, graveled or salt-spread roads
D - Driving in areas using salt or other corrosive materials or in very cold
weather
E - Driving in sandy areas
F - Driving in heavy traffic area over 32°C(90°F)
G - Driving on uphill, downhill, or mountain road
H - Towing a Trailer, or using a camper, or roof rack
I - Driving as a patrol car, taxi, other commercial use or vehicle
towing
J - Driving over 170 Km/h(100 MPH)
K - Frequently driving in stop-and-go conditions
MAINTENANCE UNDER SEVERE USAGE CONDITIONS
MAINTENANCE INTERVALS
ENGINE OIL AND FILTER
AIR CLEANER FILTER
SPARK PLUGS
TIMING BELT (WHEN REPLACE TIMING BELT AND INPECT WATER PUMP
(2.7 GSL)
BRAKE PADS, CALIPERS AND ROTORS
REAR BRAKE DRUMS/LININGS/PADS, PARKING BRAKE
STEERING GEAR BOX, LINKAGE & BOOTS/LOWER ARM BALL JOINT
DRIVE SHAFTS AND BOOTS
MANUAL TRANSAXLE OIL
AUTOMATIC TRANSAXLE
FLUID
CLIMATE CONTROL AIR FILTER
TRANSFER CASE OIL (4WD) *1
REAR AXLE OIL (4WD) *1
PROPELLER SHAFT (4WD)
(add the grease if necessary)
A, B, C, F, G, H, I, K
A, B, C, F, H, I, J, K
C, E
B, H
D, E, F, G
C, D, G, H
C, D, G, H
C, D, E, F
C, D, E, F
A, C, D, E, F, G, H, I, J
A, C, E, F, G, H, I
C, E
C, E, G, I
C, E, G, I
C
MAINTENANCE ITEM
DRIVING
CONDITION
EVERY 5,000 KM OR 6 MONTHS
EVERY 7,500 KM OR 6 MONTHS
EVERY 7,500 KM OR 6 MONTHS
MORE FREQUENTLY
MORE FREQUENTLY
EVERY 60,000 KM OR 48 MONTHS
MORE FREQUENTLY
MORE FREQUENTLY
MORE FREQUENTLY
EVERY 15,000 KM OR 12 MONTHS
EVERY 100,000 KM
EVERY 45,000 KM
EVERY 40,000 KM
MORE FREQUENTLY
EVERY 40,000 KM
EVERY 80,000 KM
EVERY 15,000 KM OR 12 MONTHS
European Community Only
Except European Community
R
R
R
R
I
I
I
I
R
R
R
R
R
I
MAINTENANCE
OPERATION
*1. Transfer Case Oil and Rear Axle Oil should be changed anytime they have been submerged in water.
GASOLINE For Middle East
Except Middle East
DIESEL
English 
