1995-2002 Suzuki Baleno 4 Door Inspection and Maintenance -> Maintenance recommended under severe driving conditions - For K10C engine model User Manual
MyCarUserManual.com
USER MANUALS FOR EVERY MAKE & MODEL

Inspection and Maintenance -> Maintenance recommended under severe driving conditions - For K10C engine model for Your Suzuki Baleno 4 Door First Generation (1995-2002)

7-8
INSPECTION AND MAINTENANCE
68PM2-01E
Maintenance recommended under severe driving conditions - For K10C engine model
Follow this schedule if your vehicle is mainly operated under one or more of the following conditions:
• When most trips are less than 6 km (4 miles).
• When most trips are less than 16 km (10 miles) and outside temperature remains below freezing.
• Idling and/or low-speed operation in stop-and-go traffic.
• Operating in extremely cold weather and/or on salted roads.
• Operating in rough and/or muddy areas.
• Operating in dusty areas.
• Repeated high speed drive or high engine revolutions.
• Towing a trailer, if admitted.
Schedule should also be followed if the vehicle is used for delivery service, police, taxi or other commercial applications.
7-9
INSPECTION AND MAINTENANCE
68PM2-01E
Interval: This interval should be judged by
odometer reading or months, whichever comes
first.
km (x1000) 7.5 15 22.5 30 37.5 45
miles (x1000) 4.5 9 13.5 18 22.5 27
months 6 12 18 24 30 36
ENGINE
*1-1. Engine accessory drive belt Tension check, *Adjustment, *Replacement – I – I – R
1-2. Engine oil and engine oil filter R R R R R R
Refer to “Oil change request light” in “BEFORE DRIVING” sec-
tion.
1-3. Engine coolant – – – – – R
*1-4. Exhaust system (except catalyst) – – – I – –
IGNITION
2-1. Spark plugs Iridium plug Replace every 30000 km (18750 miles) or 24 months.
FUEL
3-1. Air cleaner filter element*
1
Inspect every 2500 km (1562 miles).
Replace every 30000 km (18750 miles) or 24 months.
*3-2. Fuel lines – – – I – –
*3-3. Fuel tank – – – – – I
EMISSION CONTROL SYSTEM
*4-1. PCV valve – – – – – –
*4-2.
Fuel evaporative emission control system
– – – – – –
7-10
INSPECTION AND MAINTENANCE
68PM2-01E
Interval: This interval should be judged by
odometer reading or months, whichever comes
first.
km (x1000) 52.5 60 67.5 75 82.5 90
miles (x1000) 31.5 36 40.5 45 49.5 54
months 42 48 54 60 66 72
ENGINE
*1-1. Engine accessory drive belt Tension check, *Adjustment, *Replacement – I – I – R
1-2. Engine oil and engine oil filter R R R R R R
Refer to “Oil change request light” in “BEFORE DRIVING” sec-
tion.
1-3. Engine coolant – – – – – R
*1-4. Exhaust system (except catalyst) – I – – – I
IGNITION
2-1. Spark plugs Iridium plug Replace every 30000 km (18750 miles) or 24 months.
FUEL
3-1. Air cleaner filter element*
1
Inspect every 2500 km (1562 miles).
Replace every 30000 km (18750 miles) or 24 months.
*3-2. Fuel lines – I – – – I
*3-3. Fuel tank – – – – – I
EMISSION CONTROL SYSTEM
*4-1. PCV valve – – – – – I
*4-2.
Fuel evaporative emission control system
– – – – – I
7-11
INSPECTION AND MAINTENANCE
68PM2-01E
#1: Clutch fluid is supplied from brake fluid reservoir.
Interval: This interval should be judged by
odometer reading or months, whichever
comes first.
km (x1000) 7.5 15 22.5 30 37.5 45
miles (x1000) 4.5 9 13.5 18 22.5 27
months 6 12 18 24 30 36
BRAKE
*5-1. Brake discs and pads (front) (rear (if equipped)) – I – I – I
Brake drums and shoes (rear (if equipped)) – – – I – –
*5-2. Brake hoses and pipes – – – I – –
*5-3. Brake fluid (#1) – – – R – –
*5-4. Brake (Pedal and fluid level) – I – I – I
5-5. Brake lever and cable
Check, *Adjustment (1st 15000 km only)
– I – – – –
CHASSIS AND BODY
*6-1. Clutch fluid (#1) – – – R – –
*6-2. Clutch (Pedal and fluid level) – I – I – I
6-3. Tires/Wheels – I – I – I
*6-4. Wheel bearings – I – I – I
*6-5. Drive axle boots – I – I – I
*6-6. Suspension system – – – I – –
*6-7. Steering system – – – I – –
*6-8.
Manual transaxle oil Genuine “SUZUKI GEAR OIL 75W-80”
Inspect every 30000 km (18000 miles) or 24 months.
Replace every 60000 km (36000 miles) or 48 months.
Other than “SUZUKI GEAR OIL 75W-80”
– – – R – –
*6-9. Automatic transaxle Fluid leak check – – – I – –
6-10. All latches, hinges and locks – – – I – –
*6-11. Air conditioner filter element (if equipped)*
2
– I – I – R
WARNING
The shock absorbers are filled with high pressure gas. Never attempt to disassemble them or throw them into a fire. Avoid
storing them near a heater or heating device. When scrapping the absorber, the gas must be released from the absorber
safely. Ask your dealer for assistance.
7-12
INSPECTION AND MAINTENANCE
68PM2-01E
#1: Clutch fluid is supplied from brake fluid reservoir.
NOTE:
This table shows the service schedule up to 90000 km (54000 miles).
Beyond 90000 km (54000 miles), perform the same services at the same intervals shown in the chart.
*1 Inspect more frequently if the vehicle is used under dusty conditions.
*2 Clean more frequently if the air flow from the air conditioner decreases.
Interval: This interval should be judged by
odometer reading or months, whichever
comes first.
km (x1000) 52.5 60 67.5 75 82.5 90
miles (x1000) 31.5 36 40.5 45 49.5 54
months 42 48 54 60 66 72
BRAKE
*5-1. Brake discs and pads (front) (rear (if equipped)) – I – I – I
Brake drums and shoes (rear (if equipped)) – I – – – I
*5-2. Brake hoses and pipes – I – – – I
*5-3. Brake fluid (#1) – R – – – R
*5-4. Brake (Pedal and fluid level) – I – I – I
5-5. Brake lever and cable
Check, *Adjustment (1st 15000 km only)
– – – – – –
CHASSIS AND BODY
*6-1. Clutch fluid (#1) – R – – – R
*6-2. Clutch (Pedal and fluid level) – I – I – I
6-3. Tires/Wheels – I – I – I
*6-4. Wheel bearings – I – I – I
*6-5. Drive axle boots – I – I – I
*6-6. Suspension system – I – – – I
*6-7. Steering system – I – – – I
*6-8.
Manual transaxle oil Genuine “SUZUKI GEAR OIL 75W-80”
Inspect every 30000 km (18000 miles) or 24 months.
Replace every 60000 km (36000 miles) or 48 months.
Other than “SUZUKI GEAR OIL 75W-80”
– R – – – R
*6-9. Automatic transaxle Fluid leak check – I – – – I
6-10. All latches, hinges and locks – I – – – I
*6-11. Air conditioner filter element (if equipped)*
2
– I – I – R

Related Topics

Inspection and Maintenance
Maintenance schedule Periodic maintenance schedule - For K10C engine model Periodic maintenance schedule - For K12C engine model Maintenance recommended under severe driving conditions - For K12C engine model Drive belt Engine oil and filter Engine coolant Air cleaner Spark plugs Gear oil Clutch pedal Continuously Variable Transaxle (CVT) fluid Brakes Steering Tires Battery Fuses Headlight aiming Bulb replacement Wiper blades Windshield washer fluid Air conditioning system

Popular Owner Manuals

Audi
Audi
BMW
BMW
Citroen
Citroen
Ford
Ford
Honda
Honda
Peugeot
Peugeot