1995-2002 Suzuki Baleno 4 Door Inspection and Maintenance -> Periodic maintenance schedule - For K12C engine model User Manual
MyCarUserManual.com
USER MANUALS FOR EVERY MAKE & MODEL

Inspection and Maintenance -> Periodic maintenance schedule - For K12C engine model for Your Suzuki Baleno 4 Door First Generation (1995-2002)

7-13
INSPECTION AND MAINTENANCE
68PM2-01E
Periodic maintenance schedule - For K12C engine model
“R” : Replace or Change
“I” : Inspect, clean, adjust, lubricate or replace as necessary
NOTE:
This table shows the service schedule up to 240000 km (150000 miles). Beyond 240000 km (150000 miles), perform the same services
at the same intervals shown in the chart.
7-14
INSPECTION AND MAINTENANCE
68PM2-01E
#1: For further details, see “Engine oil and filter” in this section.
Interval: This interval should be judged by
odometer reading or months, whichever comes
first.
km (x1000) 20 40 60 80 100 120
miles (x1000) 12.5 25 37.5 50 62.5 75
months 12 24 36 48 60 72
ENGINE
*1-1. Engine accessory drive belt [with SHVS] Tension check, *Adjustment, *Replacement – I – R – I
[without SHVS]
Tension check, *Adjustment, *Replacement – I – I – R
1-2. Engine oil and engine oil filter ACEA Standards or SUZUKI GENUINE OIL (#1) R R R R R R
Refer to “Oil change request light” in “BEFORE DRIVING” section.
Other than ACEA Standards or SUZUKI GENUINE OIL (#1) Replace every 15000 km (9375 miles) or 12 months.
Refer to “Oil change request light” in “BEFORE DRIVING” section.
1-3. Engine coolant Replace every 40000 km (25000 miles) or 36 months.
*1-4. Exhaust system (except catalyst) – I – I – I
IGNITION
2-1. Spark plugs When unleaded fuel is used Iridium plug Replace every 100000 km (62500 miles) or 84 months.
Spark plugs When leaded fuel is used, refer to “Severe driving condition” schedule.
FUEL
3-1. Air cleaner filter element Paved-road Inspect every 20000 km (12500 miles) or 12 months.
Replace every 40000 km (25000 miles) or 36 months.
Dusty condition Refer to “Severe driving condition” schedule.
*3-2. Fuel lines – I – I – I
*3-3. Fuel tank – I – I – I
7-15
INSPECTION AND MAINTENANCE
68PM2-01E
#1: For further details, see “Engine oil and filter” in this section.
Interval: This interval should be judged by
odometer reading or months, whichever comes
first.
km (x1000) 140 160 180 200 220 240
miles (x1000) 87.5 100 112.5 125 137.5 150
months 84 96 108 120 132 144
ENGINE
*1-1. Engine accessory drive belt [with SHVS] Tension check, *Adjustment, *Replacement – R – I – R
[without SHVS]
Tension check, *Adjustment, *Replacement – I – I – R
1-2. Engine oil and engine oil filter ACEA Standards or SUZUKI GENUINE OIL (#1) R R R R R R
Refer to “Oil change request light” in “BEFORE DRIVING” section.
Other than ACEA Standards or SUZUKI GENUINE OIL (#1) Replace every 15000 km (9375 miles) or 12 months.
Refer to “Oil change request light” in “BEFORE DRIVING” section.
1-3. Engine coolant Replace every 40000 km (25000 miles) or 36 months.
*1-4. Exhaust system (except catalyst) – I – I – I
IGNITION
2-1. Spark plugs When unleaded fuel is used Iridium plug Replace every 100000 km (62500 miles) or 84 months.
Spark plugs When leaded fuel is used, refer to “Severe driving condition” schedule.
FUEL
3-1. Air cleaner filter element Paved-road Inspect every 20000 km (12500 miles) or 12 months.
Replace every 40000 km (25000 miles) or 36 months.
Dusty condition Refer to “Severe driving condition” schedule.
*3-2. Fuel lines – I – I – I
*3-3. Fuel tank – I – I – I
7-16
INSPECTION AND MAINTENANCE
68PM2-01E
#2: Clutch fluid is supplied from brake fluid reservoir.
Interval: This interval should be judged by
odometer reading or months, whichever
comes first.
km (x1000) 20 40 60 80 100 120
miles (x1000) 12.5 25 37.5 50 62.5 75
months 12 24 36 48 60 72
EMISSION CONTROL SYSTEM
*4-1. PCV valve – – – I – –
*4-2. Fuel evaporative emission control system – – – – – I
BRAKE
*5-1. Brake discs and pads (front) (rear (if equipped)) I I I I I I
Brake drums and shoes (rear (if equipped)) – I – I – I
*5-2. Brake hoses and pipes – I – I – I
*5-3. Brake fluid (#2) – R – R – R
*5-4. Brake (Pedal and fluid level) I I I I I I
5-5. Brake lever and cable
Check, *Adjustment (1st 20000 km only)
I – – – – –
CHASSIS AND BODY
*6-1. Clutch fluid (#2) – R – R – R
*6-2. Clutch (Pedal and fluid level) I I I I I I
6-3. Tires/Wheels I I I I I I
*6-4. Drive axle boots – I – I – I
*6-5. Suspension system – I – I – I
*6-6. Steering system – I – I – I
*6-7.
Manual transaxle oil Genuine “SUZUKI GEAR OIL 75W-80”
Inspect every 40000 km (25000 miles) or 24 months.
Replace every 160000 km (100000 miles) or 96 months.
Other than “SUZUKI GEAR OIL 75W-80”
– R – R – R
6-8. Continuously variable transaxle (CVT) Fluid level – I – I – I
6-9. All latches, hinges and locks – I – I – I
*6-10. Air conditioner filter element (if equipped) – I R – I R
WARNING
The shock absorbers are filled with high pressure gas. Never attempt to disassemble them or throw them into a fire. Avoid
storing them near a heater or heating device. When scrapping the absorber, the gas must be released from the absorber
safely. Ask your dealer for assistance.
7-17
INSPECTION AND MAINTENANCE
68PM2-01E
#2: Clutch fluid is supplied from brake fluid reservoir.
Interval: This interval should be judged by
odometer reading or months, whichever
comes first.
km (x1000) 140 160 180 200 220 240
miles (x1000) 87.5 100 112.5 125 137.5 150
months 84 96 108 120 132 144
EMISSION CONTROL SYSTEM
*4-1. PCV valve – I – – – I
*4-2. Fuel evaporative emission control system – – – – – I
BRAKE
*5-1. Brake discs and pads (front) (rear (if equipped)) I I I I I I
Brake drums and shoes (rear (if equipped)) – I – I – I
*5-2. Brake hoses and pipes – I – I – I
*5-3. Brake fluid (#2) – R – R – R
*5-4. Brake (Pedal and fluid level) I I I I I I
5-5. Brake lever and cable
Check, *Adjustment (1st 20000 km only)
– – – – – –
CHASSIS AND BODY
*6-1. Clutch fluid (#2) – R – R – R
*6-2. Clutch (Pedal and fluid level) I I I I I I
6-3. Tires/Wheels I I I I I I
*6-4. Drive axle boots – I – I – I
*6-5. Suspension system – I – I – I
*6-6. Steering system – I – I – I
*6-7.
Manual transaxle oil Genuine “SUZUKI GEAR OIL 75W-80”
Inspect every 40000 km (25000 miles) or 24 months.
Replace every 160000 km (100000 miles) or 96 months.
Other than “SUZUKI GEAR OIL 75W-80”
– R – R – R
6-8. Continuously variable transaxle (CVT) Fluid level – I – I – I
6-9. All latches, hinges and locks – I – I – I
*6-10. Air conditioner filter element (if equipped) – I R – I R

Related Topics

Inspection and Maintenance
Maintenance schedule Periodic maintenance schedule - For K10C engine model Maintenance recommended under severe driving conditions - For K10C engine model Maintenance recommended under severe driving conditions - For K12C engine model Drive belt Engine oil and filter Engine coolant Air cleaner Spark plugs Gear oil Clutch pedal Continuously Variable Transaxle (CVT) fluid Brakes Steering Tires Battery Fuses Headlight aiming Bulb replacement Wiper blades Windshield washer fluid Air conditioning system

Popular Owner Manuals

Audi
Audi
BMW
BMW
Citroen
Citroen
Ford
Ford
Honda
Honda
Peugeot
Peugeot