Get Maintenance -> Fuses Guide for Kia Picanto 4 Door Third Generation (2019-2026)

Maintenance

Fuses

appropriate circuit fuse. If a fuse has

blown, the element inside the fuse would

Blade type

be melted.

If the electrical system does not work,

first check the driver’s side fuse panel.

Before replacing a blown fuse, discon-

nect the negative battery cable.

Always replace a blown fuse with one of

the same rating.

OSG2H071049

If the replacement fuse blows, this indi-

Cartridge type

cates an electrical problem. Avoid using

the system involved and immediately

consult a professional workshop. Kia

recommends to consult an authorised

Kia dealer/service partner.

Three kinds of fuses are used: blade

type for lower amperage rating, car-

OSG2H071050

tridge type, and multi fuse for higher

Multi fuse

amperage ratings.

WARNING

Fuse replacement

僅 Never replace a fuse with anything

but another fuse of the same rating.

僅 A higher capacity fuse could cause

OSG2H071051_2

damage and possibly a fire.

BFT

僅 Never install a wire or aluminium foil

instead of the proper fuse even as a

temporary repair. It may cause exten-

sive wiring damage and a possible

fire.

僅 Do not arbitrarily modify or addon

OSG2H071052_2

electric wiring of the vehicle.

* Left side : Normal Right side : Blown

A vehicle’s electrical system is protected

CAUTION

from electrical overload damage by

Do not use a screwdriver or any other

fuses.

metal object to remove fuses because it

This vehicle has 2 (or 3) fuse panels, one

may cause a short circuit and damage

located in the driver’s side panel bolster,

the system.

the others in the engine compartment

near the battery.

If any of your vehicle’s lights, accesso-

ries, or controls do not work, check the

$MaintenanceFusestrailers etc., the inner junction blockNOTICEcan get burned.僅 When replacing fuse, turn the ignition“OFF” and turn off switches of all elec-CAUTIONtrical devices then remove battery (-) inspect the battery cap toensure it is securely closed. If the battery僅 The actual fuse/relay panel label maycap is not securely closed, moisture maydiffer from equipped the system and damage the elec-trical 僅 When replacing a blown fuse or relayNOTICEwith a new one, make sure the newRandom wiring prohibited when ret-fuse or relay fits tightly into the equipmentThe incomplete fastening fuse orrelay may cause the vehicle wiringUse of random wiring in the vehicleand electric systems damage and amight cause danger due to failure andpossible of the vehicle’s performance.僅 Do not remove fuses, relays and ter-Using random wires especially when ret-minals fastened with bolts or infotainment or theft alarm sys-fuses, relays and terminals may betem, remote engine control, car phonefastened incompletely, and it mayor radio might damage the vehicle orcause a possible fire. If fuses, relayscause terminals fastened with bolts ornuts are blown, consult a professionalNOTICEworkshop. Kia recommends to consultRemodelling Prohibitedan authorised Kia dealer/service part-Do not try remodeling the vehicle in . It is illegal, and may affect the vehi-僅 Do not input any other objects exceptcle’s performance, durability, and or relays into fuse/relay termi-Warranty is also not provided for prob-nals such as a driver or wiring. It maylems caused by contact failure and system mal-Be aware of safety problems caused the vehicle with僅 Do not plug in screwdrivers or after-unauthorised electrical devices(lamp,market wiring into the terminal origi-black box, electrical equipment, diag-nally designed for fuse and relaysnostic device, commun$

Maintenance

Fuses

trailers etc., the inner junction block

NOTICE

can get burned.

僅 When replacing fuse, turn the ignition

“OFF” and turn off switches of all elec-

CAUTION

trical devices then remove battery (-)

terminal.

Visually inspect the battery cap to

ensure it is securely closed. If the battery

僅 The actual fuse/relay panel label may

cap is not securely closed, moisture may

differ from equipped items.

enter the system and damage the elec-

trical components.

CAUTION

僅 When replacing a blown fuse or relay

NOTICE

with a new one, make sure the new

Random wiring prohibited when ret-

fuse or relay fits tightly into the clips.

rofitting equipment

The incomplete fastening fuse or

relay may cause the vehicle wiring

Use of random wiring in the vehicle

and electric systems damage and a

might cause danger due to failure and

possible fire.

damage of the vehicle’s performance.

僅 Do not remove fuses, relays and ter-

Using random wires especially when ret-

minals fastened with bolts or

rofitting infotainment or theft alarm sys-

fuses, relays and terminals may be

tem, remote engine control, car phone

fastened incompletely, and it may

or radio might damage the vehicle or

cause a possible fire. If fuses, relays

cause fire.

and terminals fastened with bolts or

nuts are blown, consult a professional

NOTICE

workshop. Kia recommends to consult

Remodelling Prohibited

an authorised Kia dealer/service part-

Do not try remodeling the vehicle in any

ner.

way. It is illegal, and may affect the vehi-

僅 Do not input any other objects except

cle’s performance, durability, and safety.

fuses or relays into fuse/relay termi-

Warranty is also not provided for prob-

nals such as a driver or wiring. It may

lems caused by remodeling.

cause contact failure and system mal-

Be aware of safety problems caused by

function.

remodeling the vehicle with

僅 Do not plug in screwdrivers or after-

unauthorised electrical devices(lamp,

market wiring into the terminal origi-

black box, electrical equipment, diag-

nally designed for fuse and relays

nostic device, communication device,

only. The electrical system and wiring

etc.). It might cause malfunction of the

of the vehicle interior may be dam-

vehicle, wiring damage, battery dis-

aged or burned due to contact failure.

charge, connector damage, or fire. the

僅 If you directly connect the wire on the

vehicle or cause fire.

taillight or replace the bulb which is

over the regulated capacity to install

Maintenance

Fuses

If it fits loosely, consult a professional

NOTICE

workshop. Kia recommends to consult

Window tinting precaution

an authorised Kia dealer/service partner.

Window tint(especially metallic film)

If you do not have a spare, use a fuse of

might cause communication disorder or

the same rating from a circuit you may

poor radio reception, and malfunction of

not need for operating the vehicle, such

the automatic lighting system due to

as the cigarette lighter fuse.

excessive change of illumination inside

If the headlights or taillights, stoplights,

the vehicle. The solution used might also

courtesy lamp, day time running lights

flow into electric, electronic devices

(D.R.L) do not work and the fuses are

causing disorder and failure.

OK, check the fuse panel in the engine

compartment. If a fuse is blown, it must

Inner panel fuse replacement

be replaced.

1. Turn the ignition switch and all other

Memory fuse

switches off.

Your vehicle is equipped with a memory

2. Open the fuse panel cover.

fuse to prevent battery discharge if your

vehicle is parked without being operated

for prolonged periods. Use the following

procedures before parking the vehicle

for prolonged periods.

1. Turn off the engine.

2. Turn off the headlights and tail lights.

OJAPE073018R

3. Pull the suspected fuse straight out.

3. Open the driver’s side panel cover

Use the removal tool provided in the

and pull up the memory fuse.

main fuse box in the engine compart-

ment.

4. Check the removed fuse; replace it if

it is blown.

Spare fuses are provided in the instru-

ment panel fuse panel (or in the

OJAPE073019R

engine compartment fuse panel).

NOTICE

5. Push in a new fuse of the same rating,

and make sure it fits tightly in the

僅 If the memory fuse is pulled up from

clips.

the fuse panel, the warning chime,

audio, clock and interior lamps, etc.,

will not operate. Some items must be

reset after replacement. Refer to "Bat-

tery" on page 8-40.

僅 Even when the memory fuse is pulled

up, the battery can still be discharged

OJAPE073020

Maintenance

Fuses

Multi fuse

by operation of the headlights or

other electrical devices.

Engine compartment fuse

replacement

1. Turn the ignition switch and all other

switches off.

OJAPE073022

2. Remove the fuse panel cover by

NOTICE

pressing the tab and pulling the cover

up. When the blade type fuse is dis-

If the multi fuse is blown, consult a pro-

connected, remove it by using the clip

fessional workshop. Kia recommends to

designed for changing fuses located

consult an authorised Kia dealer/service

in the engine room fuse box. Upon

partner.

removal, securely insert reserve fuse

of equal quantity.

CAUTION

Do not remove fuses, relays and termi-

nals fastened with bolts or nuts. The

fuses, relays and terminals may be fas-

tened incompletely, and it may cause a

possible fire. If fuses, relays and termi-

nals fastened with bolts or nuts are

OJAPE073021

blown, consult a professional workshop.

3. Check the removed fuse; replace it if

Kia recommends to consult an

it is blown. To remove or insert the

authorised Kia dealer/service partner.

fuse, use the fuse puller in the engine

compartment fuse panel.

Fuse/relay panel description

4. Push in a new fuse of the same rating,

and make sure it fits tightly in the

Driver’s side fuse panel

clips. If it fits loosely, consult a profes-

sional workshop. Kia recommends to

consult an authorised Kia dealer/ser-

vice partner.

CAUTION

After checking the fuse panel in the

OJAPE073023R

engine compartment, securely install the

Engine compartment fuse panel

fuse panel cover through the audible

clicking sound.

If not, electrical failures may occur from

water contact.

OJAPE073024

Maintenance

Fuses

Inside the fuse/relay panel covers, you

can find the fuse/relay label describing

fuse/relay name and capacity.

NOTICE

Not all fuse panel descriptions in this

manual may be applicable to your vehi-

cle. It is accurate at the time of printing.

When you inspect the fuse panel in your

vehicle, refer to the fuse panel label.

Maintenance

Fuses

Driver’s side fuse panel

OJAPE073108L

Instrument panel (Driver’s side fuse panel)

Symbol

Fuse rating

Circuit Protected

20A

Audio, Audio/Video & Navigation Head Unit, Low DC-DC Convertor

Instrument Cluster, BCM (Body Control Module)/SLM(Seat Belt & Lighting Module), Air Conditioner

10A

Control Module, MUT(Multi Unit Test), Driver Vanity Lamp, Luggage Lamp, Room Lamp/Overhead

Console Lamp, Power Outside Mirror Switch, Photo Sensor, Blind-Spot Collision Warning

20A

Driver Door Lock Latch, Tail Gate Unlock Relay, Door Lock/Unlock Relay

20A

Power Outlet

25A

Driver Safety Power Window Module

15A

SSEM (Stop Signal Electronic Module)

15A

BCM (Body Control Module), Hazard Switch

20A

Cigarette Lighter

Maintenance

Fuses

Symbol

Fuse rating

Circuit Protected

Outside Mirror Heater, ECM (Engine Control Module)/PCM (Power train Control Module), Air Condi-

10A

tioner Control Module

10A

25A

Power Window Main Switch, Passenger Power Window Switch

20A

Driver/Passenger Seat Control Module

10A

DRL (Daytime Running Light) Relay

[Without Keyless Entry] Clutch Switch, ECM (Engine Control Module), Smart Key Control Module,

7.5A

Engine Room Junction Block (Start Relay), Inhibit Switch [With Keyless Entry] Buglar Alarm Relay

Head Lamp Right Handle side, Rear Combination Lamp Right Handle side, Illumination(+), License

7.5A

Lamp Right Handle Side

Console Switch, Driver/Passenger Seat Console Module, Room Mirror, Head Lamp Levelling Device

Actuator Left Handle side/Right Handle side, MUT(Multi Unit Test), Automated Manual Transmission

10A

Shift Indicator, E-call Module, Audio, Audio/Video&Navigation Head Unit, Air Conditioner Control Mod-

ule, Low DC-DC convertor, Clock Spring

Engine Room Junction Block(Back-Up Lamp Switch, Vacuum Pump Relay, Back Up Lamp Relay), Stop

15A

Lamp Switch, Vacuum Pressure Switch, Vehicle Speed Sensor, Clutch Sensor, Inhibit Switch, Auto-

mated Manual Transmission Shift, Automated Manual Transmission Control Module

25A

Power Window Main Switch, Passenger Power Window Switch

25A

10A

Rear Fog Lamp, Instrument Cluster

15A

Clock Spring (Heated Steering)

Head Lamp Left Handle side, Rear Combination Lamp Left Handle side, License Lamp Left Handle

7.5A

Side

7.5A

BCM (Body Control Module), Crash Pad Switch, Blind-Spot Collision Warning

7.5A

ABS (Anti-lock brake system)/ESC (Electronic Stability Control) Control Module, Diagnosis

10A

Stop Lamp Switch, Smart Key Control Module

15A

Sunroof Motor

15A

Front Fog Lamp, Instrument Cluster

7.5A

Air Conditioner Control Module, Dual Pressure Switch, Engine Room Junction Block (Blower Relay)

Engine Room Junction Block (Head Lamp Low Relay, Head Lamp High Relay), Nozzle Heater, Driver/

10A

Passenger Seat Control Module

10A

Front Radar, Front View Camera

PCM (Power train Control Module)/ECM (Engine Control Module), Smart Key Control Module/

10A

Immobiliser Module

E-CALL

10A

E-Call Module

Maintenance

Fuses

Symbol

Fuse rating

Circuit Protected

10A

Immobiliser Module

10A

7.5A

BCM (Body Control Module)/SLM(Seat Belt & Lighting Module), Smart Key Control Module

10A

Hazard Switch

10A

ACU(Airbag Control Unit)

7.5A

BCM (Body Control Module)/SLM(Seat Belt & Lighting Module)

25A

Smart Key Control Module

7.5A

Air Conditioner Control Module

15A

Multifunction Switch (Wiper)

25A

Multifunction Switch (Wiper), Front Wiper Motor

BCM (Body Control Module)/SLM(Seat Belt & Lighting Module), MTS (Mozen Telematics System) E-Call

10A

Module, Audio, Low DC-DC Convertor, Audio/Video & Navigation Head Unit, Smart Key Control Mod-

ule, Power Outside Mirror Switch, Power Outlet Relay

20A

7.5A

Instrument Cluster, Air Conditioner Control Module

7.5A

Instrument Cluster

7.5A

MDPS (Motor Driven Power Steering) Unit

Maintenance

Fuses

Engine compartment fuse panel

OJAPE073109L

Engine room compartment fuse panel [(Petrol) 1.0 MPI, 1.2 MPI],

[Smartstream G1.0, G1.2]

Symbol

Fuse rating

Circuit Protected

125A (Without ISG)

Fuse(ABS1, ABS2, RR DEFOG, POWER OUTLET, BLOWER), Alternator

150A (With ISG)

80A

MDPS (Motor Driven Power Steering) Module

ABS (Anti-lock brake system)/ESC (Electronic Stability Control) Control Module, Multipur-

40A

pose Check Connector

30A

[With Smart Key] PDM Relay Box (IG1 Relay, ACC Relay) [Without Smart Key] Ignition Switch

30A

ABS (Anti-lock brake system)/ESC (Electronic Stability Control) Control Module

Instrument Panel Junction Block (Tail Lamp Relay), Instrument Panel Junction Block

40A

Fuse(Door Lock, Hazard)

40A

Instrument Panel Junction Block (Power Outlet Relay)

30A

[Smartstream G1.0, G1.2] Main Relay (FUSE - ECU2, ECU3)

Maintenance

Fuses

Symbol

Fuse rating

Circuit Protected

40A

Instrument Panel Junction Block (Rear Defogger Relay)

40A

FUSE (AMT2, AMT3, AMT4)

40A

Blower Relay

Instrument Panel Junction Block (Power Window Relay), Instrument Panel Junction Block-

50A

Fuse (Sunroof, Seat Heater, Smart Key1, Smart Key 2, Brake Switch, Safety Power Window,

E-CALL)

10A

Head Lamp Left Handle side, Instrument Cluster

10A

Head Lamp Right Handle side

10A

Instrument Cluster

20A

Automated Manual Transmission Control Module

20A

Automated Manual Transmission Control Module

10A

ECM (Engine Control Module)/PCM (Power Train Control Module)

15A

[Smartstream G1.0, G1.2]ECM (Engine Control Module)/ PCM (Power train Control Module)

ECM (Engine Control Module)/PCM (Power train Control Module) [(Petrol) 1.0 MPI, 1.2

15A

MPI]Air Conditioner Compressor Rly, Cooling Fan Rly Oil Control Valve IN/EX(M/T), Purge

Control Solenoid Valve(M/T) Coolant Stop Valve(A/T)

Canister Close Valve, Wheel Sensor Right Handle side Oxygen Sensor Up/Down [(Petrol) 1.0

MPI, 1.2 MPI] Coolant Stop Valve(M/T) [Smartstream G1.0, G1.2] ECM(Engine Control Mod-

15A

ule)/PCM(Power train Control Module) Purge Control Solenoid Valve, Variable Intake Sole-

noid, Recirculation Valve, Oil Control Valve IN/EX Air conditioner Relay, Cooling Fan Relay,

Variable Oil Pump

ECM (Engine Control Module)/PCM (Power train Control Module), Fuel Pump Relay, Injector

15A

#1/#2/#3/#4[(Petrol engine) 1.0 MPI, 1.2 MPI]Oil Control Valve IN/EX(A/T), Purge Control

Solenoid Valve(A/T)

15A

Ignition Coil #1/#2/#3/#4 Condenser [(Petrol) 1.2 MPI]

15A (With AMT)

Automated Manual Transmission Control Module

Back-Up Lamp Switch, Instrument Cluster, Audio/Video&Navigation Head Unit, Back-up

10A (Without AMT)

Lamp, Room Mirror

Instrument Panel Junction Block Fuse(Front Fog Lamp, Rear Fog Lamp, Audio, Room Lamp,

50A

DRL, Stop Lamp)

30A

Cooling Fan Relay

20A

Head Lamp Low Relay

20A

Head Lamp High Relay

20A

Fuel Pump Relay

15A

ECM (Engine Control Module)/PCM (Power train Control Module)

15A

Horn Relay, Burglar Alarm Horn Relay

Maintenance

Fuses

Symbol

Fuse rating

Circuit Protected

10A (With AMT)

Back Up Lamp Relay

20A (With A/T)

Vacuum Pump Relay

10A

Air Conditioner Relay

30A

Start Relay, PDM Relay Box (IG2 Relay), Ignition Switch

Relay [(Petrol) 1.0 MPI, 1.2 MPI], [Smartstream G1.0, G1.2]

Symbol

Relay Name

Type

Main Relay

MINI

Air Conditioner Relay

MICRO

Start Relay

HIGH CURRENT MICRO

Blower Relay

HIGH CURRENT MICRO

Horn Relay

MICRO

Burglar Alarm Horn Relay

MICRO

Cooling Fan Relay

HIGH CURRENT MICRO

AMT Back Up Lamp Relay (With AMT)

MICRO

Vacuum Pump Relay (With A/T)

MICRO

Head Lamp Low Relay

HIGH CURRENT MICRO

Head Lamp High Relay

MICRO

Fuel Pump Relay

MICRO

Engine room compartment fuse panel [(Petrol) 1.0 FFV]

Symbol

Fuse rating

Circuit Protected

125A

Fuse(ABS1, ABS2, RR DEFOG, POWER OUTLET, BLOWER), Alternator

80A

MDPS (Motor Driven Power Steering) Module

ABS (Anti-lock brake system)/ESC (Electronic Stability Control) Control Module, Multipur-

40A

pose Check Connector

30A

[With Smart Key] PDM Relay Box (IG1 Relay, ACC Relay) [Without Smart Key] Ignition Switch

30A

ABS (Anti-lock brake system)/ESC (Electronic Stability Control) Control Module

FUSE(SUB FEUL PUMP), Instrument Panel Junction Block (Tail Lamp Relay), Instrument

40A

Panel Junction Block Fuse(Door Lock, Hazard)

40A

Instrument Panel Junction Block (Power Outlet Relay)

$MaintenanceFusesSymbolFuse ratingCircuit Protected30AMain Relay40AInstrument Panel Junction Block (Rear Defogger Relay)40ABlower RelayInstrument Panel Junction Block (Power Window Relay), Instrument Panel Junction Block50AFuse(Sunroof, Seat Heater, Smart Key1, Smart Key 2, Brake Switch, Safety Power Window)10AHead Lamp Left Handle side, Instrument Cluster10AHead Lamp Right Handle side10AInstrument Cluster20ASub Fuel Pump Relay10AECM (Engine Control Module)/PCM (Power Train Control Module)ECM (Engine Control Module)/PCM (Power train Control Module) [M/T] Purge Control Sole-15Anoid Valve, Oil Control Valve IN, Oxygen Sensor Up/Down, Air conditioner Relay, Fuel PumpRelay, Camshaft Position Sensor IN [A/T] Cooling Fan Relay[M/T] Cooling Fan Relay[A/T] Purge Control Solenoid Valve, Oil Control Valve IN, Oxygen15ASensor Up/Down, Air conditioner Relay, Fuel Pump Relay, Camshaft Postion Sensor INECM (Engine Control Module)/PCM (Power train Control Module), Injector #1/#2/#3, Sub15AFuel Pump Relay15AIgnition Coil #1/#2/#3, CondenserBack-Up Lamp Switch, Instrument Cluster, Audio/Video&Navigation Head Unit, Back-up10ALamp, Room MirrorInstrument Panel Junction Block Fuse (Front Fog Lamp, Rear Fog Lamp, Audio, Room50ALamp, DRL, Stop Lamp)30ACooling Fan Relay20AHead Lamp Low Relay20AHead Lamp High Relay20AFuel Pump Relay15AECM (Engine Control Module)/PCM (Power train Control Module)15AHorn Relay, Burglar Alarm Horn Relay10AAir Conditioner Relay30AStart Relay, PDM Relay Box (IG2 Relay), Ignition Switch862$

Maintenance

Fuses

Symbol

Fuse rating

Circuit Protected

30A

Main Relay

40A

Instrument Panel Junction Block (Rear Defogger Relay)

40A

Blower Relay

Instrument Panel Junction Block (Power Window Relay), Instrument Panel Junction Block

50A

Fuse(Sunroof, Seat Heater, Smart Key1, Smart Key 2, Brake Switch, Safety Power Window)

10A

Head Lamp Left Handle side, Instrument Cluster

10A

Head Lamp Right Handle side

10A

Instrument Cluster

20A

Sub Fuel Pump Relay

10A

ECM (Engine Control Module)/PCM (Power Train Control Module)

ECM (Engine Control Module)/PCM (Power train Control Module) [M/T] Purge Control Sole-

15A

noid Valve, Oil Control Valve IN, Oxygen Sensor Up/Down, Air conditioner Relay, Fuel Pump

Relay, Camshaft Position Sensor IN [A/T] Cooling Fan Relay

[M/T] Cooling Fan Relay[A/T] Purge Control Solenoid Valve, Oil Control Valve IN, Oxygen

15A

Sensor Up/Down, Air conditioner Relay, Fuel Pump Relay, Camshaft Postion Sensor IN

ECM (Engine Control Module)/PCM (Power train Control Module), Injector #1/#2/#3, Sub

15A

Fuel Pump Relay

15A

Ignition Coil #1/#2/#3, Condenser

Back-Up Lamp Switch, Instrument Cluster, Audio/Video&Navigation Head Unit, Back-up

10A

Lamp, Room Mirror

Instrument Panel Junction Block Fuse (Front Fog Lamp, Rear Fog Lamp, Audio, Room

50A

Lamp, DRL, Stop Lamp)

30A

Cooling Fan Relay

20A

Head Lamp Low Relay

20A

Head Lamp High Relay

20A

Fuel Pump Relay

15A

ECM (Engine Control Module)/PCM (Power train Control Module)

15A

Horn Relay, Burglar Alarm Horn Relay

10A

Air Conditioner Relay

30A

Start Relay, PDM Relay Box (IG2 Relay), Ignition Switch

Maintenance -> Fuses for Your Kia Picanto 4 Door Third Generation (2019-2026)

Related Topics

Popular Owner Manuals

Latest Owner Manuals