Get INSPECTION AND MAINTENANCE -> Maintenance recommended under severe driving conditions (for EU countries and Israel) Guide for Suzuki Jimny SUV Fourth Generation (2018-2026)

INSPECTION AND MAINTENANCE

Maintenance recommended under severe driving conditions (for EU countries and Israel)

Follow this schedule if your vehicle is mainly operated under one or more of the following conditions:

• When most trips are less than 6 km (4 miles).

When most trips are less than 16 km (1 O miles) and outside temperature remains below freezing.

Idling and/or low-speed operation in stop-and-go traffic.

Operating in extremely cold weather and/or on salted roads.

Operating in rough and/or muddy areas.

Operating in dusty areas.

Repeated high speed drive or high engine revolutions.

Towing a trailer, if admitted.

Schedule should also be followed if the vehicle is used for delivery service, police, taxi or other commercial applications.

6-18

INSPECTION AND MAINTENANCE

Interval: This interval should be judged byl

km (x1000)I

10

I

20

I

30

I

40

I

50

I

60

odometer reading or months, whichever comes

I miles (x1000)I

6.25

I

12.5

I

18.75 I 25 I 31.25 I

37.5

ft~ I

months!

6

I

12

I

18

I

24 I

30

I

36

ENGINE

*1-1. Engine accessory drive belt

Tension check, *Adjustment, *Replacement

-

I

-

I

-

I

R

*1-2. Valve clearance

-

I -

-

1-3. Engine oil and engine oil filter

ACEA Standards or SUZUKI GENUINE OIL (#1)

R

R R

R

Refer to "Oil change reminder light" In the "BEFORE DRIVING" sec-

Uon.

Other than ACEA Standards or SUZUKI GENUINE OIL (#1)

Replace every 7500 km (4687 miles) or 6 months.

Refer to "011 change reminder light" in the "BEFORE DRIVING" sec-

tion.

1-4. Engine· coolant

SUZUKI LLC: Super (Blue) (#2)

First time only:

Replace at 160000 km (100000 miles) or 96 months.

Second time and after:

Replace every 80000 km (50000 miles) or 48 months.

SUZUKI LLC: Standard (Green)

Replace every 40000 km (25000 miles) or 36 months.

*1-5. Exhaust system (except catalyst)

- I - I - I I I - I

-

IGNITION

2-1. Spark plugs

Iridium plug

!Replace every 30000 km (18750 miles) or 24 months.

FUEL

3-1. Air cleaner filter element"

1

Inspect every 2500 km (1562 miles).

Replace every 30000 km (18750 miles) ol 24 months.

*3-2. Fuel lines

- I - I - I I - I

-

*3-3. Fuel tank

- - - I -

-

EMISSION CONTROL SYSTEM

*4-1. PCV valve

!Inspect every 80000 km (50000 miles) or fB monthsi

*4-2. Fuel evaporative emission control system

-1-1-1- -

-

#1: For further details, see "Engine oil and filter" in this section.

#2: Perform the engine coolant level check under the daily inspection in the "OPERATING YOUR VEHICLE" section.

If you use the engine coolant other than "SUZUKI LLC: Super (Blue)" for replacement, follow the schedule of "SUZUKI LLC: Standard

(Green)". (Replace every 40000 km (25000 miles) or 36 months.)

6-19

INSPECTION AND MAINTENANCE

Interval: This interval should be judged byl

km (x1000) 70

I

80

I

90

I

100

I

110

I

120

odometer reading or months, whichever comesi miles (x1000) 43.75 I 50

I

56.25 I

62.5 I

68.75 I

75

first. I

months

42

I

48

I

54

I

60

I

66

I

72

ENGINE

*1-1. Engine accessory drive bell

Tension check, *Adjustment, *Replacement

-

I

-

I

-

I

R

*1-2. Valve clearance

-

I

-

- I

1-3. Engine oil and engine oil filter

ACEA Standards or SUZUKI GENUINE OIL (#1)

R

R R

R

Refer to "Oil change reminder light" in the "BEFORE DRIVING" sec-

tion.

Other than ACEA Standards or SUZUKI GENUINE OIL (#1)

Replace every 7500 km (4687 miles) or 6 months.

Refer to "Oil change reminder light" in the "BEFORE DRIVING" sec-

lion.

1-4. Engine coolant

SUZUKI LLC: Super (Blue) (#2)

First time only:

Replace at 160000 km (100000 miles) or96 months.

Second time and after:

Replace every 80000 km (50000 miles) or 48 months.

SUZUKI LLC:

Standard (Green)

Replace erery 4000~ km (2500

1

0 miles) 0136 months.

*1-5. Exhaust system (except catalyst)

- I - - - I

I

IGNITION

2-1. Spark plugs

Iridium plug

!Replace every 30000 km (18750 miles) or 24 months.

FUEL

3-1. Air cleaner filter element*

1

Inspect every 2500 km (1562 miles).

Replace every 30000 km (18750 miles) or 24 months.

*3-2. Fuel lines

= I : I = I = I = I

I

*3-3. Fuel tank

I

EMISSION CONTROL SYSTEM

*4-1. PCV valve

*4-2. Fuel evaporative emission control system

!Inspect every 80000 km (50000 miles) or 48 months.

I - I I I - I

I

#1: For further details, see "Engine oil and filter" in this section.

#2: Perform the engine coolant level check under the daily inspection in the "OPERATING YOUR VEHICLE" section.

If you use the engine coolant other than "SUZUKI LLC: Super (Blue)" for replacement, follow the schedule of "SUZUKI LLC: Standard

(Green)". (Replace every 40000 km (25000 miles) or 36 months.)

6-20

INSPECTION AND MAINTENANCE

Interval: This interval should be judged byl, -----------------------=~"-f""'~----a'ica-l--i;ee+

odometer reading or months, whicheveq,r ___________________ =='='c~:,f-"'ii"-+-:;;;'----!-

km (x100D)

10

I

20

I 30 I 40

I 50 I 60

miles (x1000)

6.25 I

12.5 I 18.75 I

25 I 31,25 I 37.5

comes first. I

BRAKE

*5-1. Brake discs and pads (front)

Brake drums and shoes (rear)

*5-2. Brake hoses and pipes

5-3. Brake fluid (#3)

months

Check, *Replacement

*5-4. Brake (Pedal and fluid level)

5-5. Brake lever and cable

Check, *Adjustment (1st 20000 km only)

CHASSIS ANO BODY

*6-1. Clutch fluid (#3)

*6-2. Clutch (Pedal and fluid level)

6-3. Tyres/Wheels

*6-4. Wheel bearings

*6-5. Propeller shafts

*6-6. Suspension system

*6-7. Steering system

*6-8. Manual transmission oil

6-9. Automatic transmission

*6-10. Transfer oil

*6-11. Differential all

6-12. All latches, hinges and locks

*6-13. Air conditioner filter elemenr·

3

Genuine "SUZUKI GEAR OIL 75W"

Other than "SUZUKI GEAR OIL 75W"

Genuine "SUZUKI GEAR OIL 75W"

Other than "SUZUKI GEAR OIL 75W"

Fluid level

*Fluid change

*Fluid hose

Genuine "SUZUKI SUPER GEAR OIL 75W-85 SYNTHETIC"

#3: Clutch fiuid is supplied from brake fiuid reservoir.

A WARNING

6

I

12

I

18

I 24

I

30

I 36

-

I

-

I

-

I

-

I

-

- -

I -

-

R -

-

I -

I

-

I -

-

R

-

I

-

I

-

I

-

I

-

I

-

I

-

I -

I

-

I -

I

-

I -

-

I -

-

Inspect every 20000 km (12500 miles) or 12 months.

Replace every 80000 km (50000 miles) or 48 months.

= I I = I I = I

Replace every 30000 km (18000 miles).

Inspect every 60000 km (37500 miles).

Inspect every 20000 km (12500 miles) or 12 months.

Replace every 80000 km (50000 miles) or 48. months.

- R - R - R

- R - - - R

R

The shock absorbers are filled with high pressure gas. Never attempt to disassemble them or throw them into a fire. Avoid

storing them near a heater or heating device. When scrapping the absorber, the gas must be released from the absorber

safely. Ask your dealer for assistance.

6-21

INSPECTION AND MAINTENANCE

Interval: This interval should be judged byI km (x1000)I

70 I

80

I 90 I

100 I 110 120

odometer reading or months,

whicheveq

miles (x1000l/ 43.75 50 56.25 I 62.5 I 68. 75 75

comes first.

I

months 42 48 54

I

60

I

66

72

BRAKE

*5-1. Brake discs and pads (front)

- I - I - I

Brake drums and shoes (rear) - I

-

- I

*5-2. Brake hoses and pipes

-

I

-

I

5-3. Brake fluid (#3) Check, *Replacement - R -

-

- R

*5-4. Brake (Pedal and fluid level)

-

I

-

I - I

5-5. Brake lever and cable Check, *Adjustment (1 st 20000 km onlv

-

CHASSIS AND BODY

*6-1. Clutch fluid (#3)

*6-2. Clutch (Pedal and fluid level)

6-3. Tyres/Wheels

*6-4. Wheel bearings

*6-5. Propeller shafts

*6-6. Suspension system

*6-7. Steering system

*6-8. Manual transmission

oil Genuine "SUZUKI GEAR OIL 75W"

Other than "SUZUKI GEAR OIL 75W"

6-9. Automatic transmission Fluid level

*Fluid change

*Fluid hose

*6-10. Transfer oil Genuine "SUZUKI GEAR OIL 75W"

Other than

"SUZUKI GEAR OIL 75W"

*6-11. Differential oil Genuine "SUZUKI SUPER GEAR OIL 75W-85 SYNTHETIC"

6-12. All latches, hinges and locks

*6-13. Air conditioner filter element *

3

#3: Clutch fluid 1s supplied from brake fluid reservoir.

NOTE:

This table shows the service schedule up to 120000 km (75000 miles).

-

R

-

R

- I

-

I

-

I

- I - I - I

-

I

-

I

-

I

-

I

-

I

- I -

-

- I

-

I

-

I

Inspect every 20000 km (12500 miles) or 12 months.

Replace every 80000 km (50000 miles) or 48 months.

- I R I - I R I - I R

- I - I - I

Replace every 30000 km (18000 miles).

Inspect every 60000 km (37500 miles).

Inspect every 20000 km (12500 miles) or 12 months.

Replace every 80000 km (50000 mlles) or48 months.

-

R

-

R

-

R

-

- R -

-

- I -

-

- I

-

I

-

I

-

R

Beyond 120000 km (75000 miles), perform the same services at the same intervals shown in the chart.

•1 Inspect more frequently if the vehicle is used under dusty conditions.

•2 Check or replace as necessary if you usually drive with high speed or high engine revolutions.

•3 Clean more frequently if the air flow from the air conditioner decreases.

6-22

INSPECTION AND MAINTENANCE -> Maintenance recommended under severe driving conditions (for EU countries and Israel) for Your Suzuki Jimny SUV Fourth Generation (2018-2026)

Related Topics

Popular Owner Manuals

Latest Owner Manuals