Get INSPECTION AND MAINTENANCE -> Periodic maintenance schedule (except for EU countries and Israel) Guide for Suzuki Jimny SUV Fourth Generation (2018-2026)

INSPECTION AND MAINTENANCE

Periodic maintenance schedule (except for EU countries and Israel)

"R" : Replace or Change

11

1" : Inspect, clean, adjust, lubricate or replace as necessary

NOTE:

This table shows the service schedule up to 180000 km (108000 miles). Beyond 180000 km (108000 miles), perform the same services

at the same intervals shown in the chart.

NOTE:

For the Periodic Maintenance Schedule of Russian models, refer to "For Russia" in the "SUPPLEMENT" section.

6-3

INSPECTION AND MAINTENANCE

Interval: This interval should be judged by1

km (x1000) 15

I

30

I

45

I

60

I

75

I

90

odometer reading or months, whichever comes

I

miles (x1000) 9

I

18

I

27

I

36

I

45

I

54

first.

1

months 12

I

24

I

36

I

48

I

60

I 72

ENGINE

*1-1. Engine accessory drive bell Tension check, *Adjustment, *Replacement

-

I

-

I

-

I

-

I

R

*1-2. Valve clearance

-

I

- I - I

1-3. Engine oil and engine oil filter

R R R

1-4. Engine coolant

SUZUKI LLC: Super (Blue) (#1) First time only:

Replace at 150000 km (90000 miles) or 96 months.

Second time and after:

Replace every 75000 km (45000 miles) or 48 months.

SUZUKI LLC: Standard (Green)

=l1l~l1l=I

R

*1-5. Exhaust system (except catalyst)

I

IGNITION

2-1. Spark plugs When unleaded fuel is used Iridium plug I Replace every 105000 km (63000 miles) or 84 months.

Nickel plug

-I-IRl-1-1

R

Spark plugs When leaded fuel is used, refer to "Severe driving conditionn schedule.

FUEL

3-1. Air cleaner filter element Paved-road

I

R

I

R

Dusty condition

Refer to "Severe driving condition" schedule.

*3-2. Fuel lines

-

I

-

I

-

I

*3-3. Fuel filter

Replace every 105000 km (63000 miles).

*3-4. Fuel tank

- I - I I I - I

-

I

EMISSION CONTROL SYSTEM

*4-1. PCV valve

I Inspect every 80000 km (50000 miles) or 48 months.

*4-2. Fuel evaporative emission control system -1-1-1-1-1

I

#1: Perform the engine coolant level check under the daily inspection in the "OPERATING YOUR VEHICLE" section.

If you use the engine coolant other than "SUZUKI LLC: Super (Blue)" for replacement, follow the schedule of "SUZUKI LLC: Stan-

dard (Green)". (Replace every 45000 km (27000 miles) or 36 months.)

6-4

INSPECTION AND MAINTENANCE

Interval: This interval should be judged byl

km (X1000)

105

I

120

I

135

I

150

I

165

I

180

odometer reading or months, whichever comesI

miles (x1000)

63

I

72

I

81

I

90

I

99

I

108

first. I

months 84

I

96

I

108

I

120

I

132

I

144

ENGINE

*1-1. Engine accessory drive belt

Tension check, • Adjustment, *Replacement

-

I

-

I

-

I

-

I

R

*1-2. Valve clearance

-

I

-

I

-

I

1-3. Engine oil and engine oil filter

R R R R R R

1-4. Engine coolant

SUZUKI LLC: Super (Blue) (#1)

First time only: Replace at 150000 km (90000 miles) or 96 months.

Second time and after: Replace every 75000 km (45000 miles) or 48 months.

SUZUKI LLC: Standard (Green)

=l~l~l~l=I

R

*1-5. Exhaust system (except catalyst)

I

IGNITION

2-1. Spark plugs When unleaded fuel is used Iridium plug

I Replace every 105000 km (63000 miles) or 84 monlhs.

Nickel plug

-I-IRl-1-1

R

Spark plugs When leaded fuel is used, refer to "Severe driving condition" schedule.

FUEL

3-1. Air cleaner filter element

Paved-road

I

R

I

R

Dusty condition Refer to MSevere driving condition" schedule.

*3-2. Fuel lines

-

I

-

I

-

I

*3-3. Fuel filter

Replace every 105000 km (63000 miles).

*3-4. Fuel tank

- I - I I I - I - I

I

EMISSION CONTROL SYSTEM

*4-1. PCVvalve

I Inspect every 80000 km (50000 miles) or 48 months.

'"4-2. Fuel evaporative emission control system

- I - I - I - I - I

I

#1: Perform the engine coolant level check under the daily inspection in the "OPERATING YOUR VEHICLE" section.

If you use the engine coolant other than "SUZUKI LLC: Super (Blue)" for replacement, follow the schedule of "SUZUKI LLC: Stan-

dard (Green)". (Replace every 45000 km (27000 miles) or 36 months.)

6-5

INSPECTION AND MAINTENANCE

Interval: This interval should be judged byI

km (x1000)I

15

I

30

I

45

I 60 I 75

90

odometer reading or months, whichever,

miles (x1000)I

9

I

18

I

27

I 36 I 45

54

comes first.

1 monthsI 12 I 24 I

36

I 48 I 60 I 72

BRAKE

*5-1. Brake discs and pads (front)

I I

Brake drums and shoes (rear)

-

I -

I

-

I

*5-2. Brake hoses and pipes

-

I -

I

-

I

5-3. Brake fluid (#2) Check, *Replacement

-

R -

R

-

R

*5-4. Brake (Pedal and fluid level)

I I I I

I

5-5. Brake lever and cable Check, *Adjustment (1st 15000 km only)

I

-

- -

CHASSIS AND BODY

*6-1. Clutch fluid (#2)

-

R

-

R

-

R

*6-2. Clutch (pedal and fluid level)

I I I I

I I

6-3. Tyres/Wheels

I I I I

I I

*6-4. Wheel bearings

-

I

-

I

-

I

*6-5. Propeller shafts

- -

I

-

I

*6-6. Suspension system

- I -

I

-

I

"6-7. Steering system

-

I -

I

-

I

*6-8. Manual transmission oil Genuine "SUZUKI GEAR OIL 75W"

Inspect every 30000 km (18000 miles) or 24 months.

Other than "SUZUKI GEAR OIL

75W" (1: 1st 15000 km only)

I

-

I

R

I

-

I

-

I

R

6-9. Automatic transmission

Fluid level

-

I

-

I

-

I

*Fluid change Replace every 165000 km (99000 miles).

*Fluid hose

-

I

-

I

-

I

-

I

-

*6-10. Transfer oil Genuine "SUZUKI GEAR OIL 75W"

Inspect every 30000 km (18000 miles) or 24 months.

Other than "SUZUKI GEAR OIL 75W"

(I: 1st 15000 km only) I

-

R

-

- R

*6-11. Differential oil

(R: 1 st 15000 km only) Genuine

"SUZUKI SUPER GEAR OIL 75W-85 SYNTHETIC"

R

-

I

-

I

-

6-12. All latches, hinges and locks

-

I

-

I - I

*6-13. Air conditioner filter element

-

I R

-

I R

#2: Clutch fluid is supplied from brake fluid reservoir.

A WARNING

The shock absorbers are filled with high pressure gas. Never attempt to disassemble them or throw them into a fire. Avoid

storing them near a heater or heating device. When scrapping the absorber, the gas must be released from the absorber

safely. Ask your dealer for assistance.

6-6

INSPECTION AND MAINTENANCE

Interval: This interval should be Judged byll---------------------=cc'c-tci.i;#----,i,c---t-----,ai--t----.sci

odometer reading or months, whicheveq

km (x1000) 105 120 135 150 165 I

180

miles (x1000)

63 72 81 90

I

99

I

108

comes first.

1>----------------------~=.c..,,-4-___,,.c...--1-___,,c----1----c~

months

84 96 108

120

I

132 I 144

BRAKE

*5-1, Brake discs and pads (front)

Brake drums and shoes (rear)

*5-2. Brake hoses and pipes

5-3. Brake fluid (#2)

*5-4. Brake (Pedal and fluid level)

5-5. Brake lever and cable

CHASSIS AND BODY

*6-1. Clutch fluid (#2)

*6-2. Clutch (pedal and fluid level)

6-3. Tyres/Wheels

*6-4. Wheel bearings

*6-5. Propeller shafts

*6-6. Suspension system

*6-7. Steering system

*6-8. Manual transmission

oil

6-9. Automatic transmission

*6-10. Transfer oil

*6-11. Differential oil

6-12.

All latches, hinges and locks

*6-13. Air conditioner filter element

Genuine "SUZUKI GEAR OIL 75W"

Otllerthan "SUZUKI GEAR OIL 75W"

Genuine "SUZUKI GEAR OIL 75W"

Check, *Replacement

Check, *Adjustment (1st 15000 km only

(I: 1st 15000 km only)

Fluid lever

*Fluid change

*Fluid hose

Other than "SUZUKI GEAR OIL 75W" (I: 1st 15000 km only)

(R: 1st 15000 km only) Genuine

"SUZUKI SUPER GEAR OIL 75W-85 SYNTHETIC"

#2: Clutch

fluid is supplied from brake fluid reseNoir.

6-7

I I

I I I I

- I

-

I

-

I

- I - I

-

I

- R

-

R

-

R

I I I I I I

-

- - -

- -

-

R

- R

-

R

I I

I I I I

I I

I I I I

- I

-

I

-

I

-

I

-

I

- I

-

I

-

I

-

I

-

I

- I

Inspect every 30000 km (18000 miles) or 24 months.

= I I I I = I 7

Replace every 165000 km (99000 miles).

- I I I - I - I - I I

Inspect every 30000 km (18000

m!les) or 24 months.

- - R - - R

I - I - I -

R

I

R

INSPECTION AND MAINTENANCE -> Periodic maintenance schedule (except for EU countries and Israel) for Your Suzuki Jimny SUV Fourth Generation (2018-2026)

Related Topics

Popular Owner Manuals

Latest Owner Manuals