Get INSPECTION AND MAINTENANCE -> Periodic maintenance schedule (for EU countries and Israel) Guide for Suzuki Jimny SUV Fourth Generation (2018-2026)

INSPECTION AND MAINTENANCE

Periodic maintenance schedule (for EU countries and Israel)

"R" : Replace or Change

"I" : Inspect, clean, adjust, lubricate or replace as necessary

NOTE:

This table shows the service schedule up to 240000 km (150000 miles). Beyond 240000 km (150000 miles), perform the same services

at the same intervals shown in the chart.

6-13

INSPECTION AND MAINTENANCE

Interval: This interval should be judged byl km (x1000)

20

I

40

I

60

I

80

I

100

I

120

odometer reading or months, whichever comes

I mi!es (x1000)

12.5

I

25

I

37.5

I

50

I

62.5

I

75

first.

I months/ 12

I

24 I

36

I

48

I

60

I

72

ENGINE

•1-1. Engine accessory drive

belt

Tension check, *Adjustment, *Replacement -

I

-

I

-

I

R

*1-2. Valve clearance

- I - I

-

I

1-3. Engine oil and engine

oil filter

ACEA Standards or SUZUKI GENUINE OIL (#1) R R

R

R R

Refer to "Oil change reminder

light" in the "BEFORE DRIVING" sec-

lion.

Other than ACEA Standards or SUZUKI GENUINE OIL (#1) Replace every 15000 km (9375 miles) or 12 months.

Refer to "Oil change reminder

light" in the "BEFORE DRIVING" sec-

lion.

1-4. Engine coolant SUZUKI LLC: Super (Blue) (#2) First

time only:

Replace at 160000 km (100000 miles) or 96 months.

Second time and after:

Replace every 80000 km (50000 miles) or 48 months.

SUZUKI LLC: Standard (Green)

Replace every 40000 km (25000 miles) or 36 months.

*1-5. Exhaust system (except catalyst)

- I I I - I I I - I

I

IGNITION

2-1. Spark plugs When unleaded fuel is used Iridium plug

!Replace every 100000 km (62500 miles) or 84 months.

Spark plugs When leaded fuel is used, refer to "Severe driving

conditiontt schedule.

FUEL

3-1. Air cleaner filter element Paved-road

Inspect every 20000 km (12500 miles) or 12 months.

Replace every 40000 km (25000

miles) or 36 months.

Dusty condition

Refer to "Severe driving

condition" schedule.

I

*3-2. Fuel lines

= I : I = I : I

- I

*3-3. Fuel tank

- I

#1: For further details, see "Engine oil and filter" in this section.

#2: Perform the engine coolant level check under the daily inspection in the "OPERATING YOUR VEHICLE" section.

If you use the engine coolant other than "SUZUKI LLC: Super (Blue)" for replacement, follow the schedule of "SUZUKI LLC: Stan-

dard (Green)". (Replace every 40000 km (25000 miles) or 36 months.)

6-14

INSPECTION AND MAINTENANCE

Interval: This interval should be judged

byl

km (x1000)I 140

I

160 I 180 I 200 I 220 I 240

odometer reading or months, whichever comes

I

miles (x1000)I 87.5

I

100 I 112.5 I 125 I 137.5

! 150

first.

1 monthsI 84 I 96 I 108 I 120 I 132 I

144

ENGINE

•1-1. Engine accessory drive belt Tension check, *Adjustment, *Replacement

-

I

-

I

-

I

R

*1-2. Valve clearance

-

I

-

I - I

1-3. Engine oil and engine oil filter ACEA Standards or SUZUKI GENUINE OIL (#1)

R

R R

R

Refer to "Oil change reminder light"

in the "BEFORE DRIVING" sec-

lion.

Other than ACEA Standards or SUZUKI GENUINE OIL (#1)

Replace every 15000 km (9375 miles) or 12 months.

Refer to "Oil change reminder light" in the "BEFORE DRIVING" sec-

lion.

1-4. Engine coolant SUZUKI LLC: Super (Blue) (#2) First time only:

Replace at 160000 km (100000 miles) or 96 months.

Second time and after:

Replace every 80000 km (50000

miles) or 48 months.

SUZUKI LLC: Standard (Green)

Replace every 40000 km (25000 miles) or 36 months.

*1-5. Exhaust system (except catalyst)

- I I I - I I I - I

I

IGNITION

2-1. Spark plugs When unleaded fuel is used Iridium plug

!Replace every 100000 km (62500 miles) or 84 months.

Spark plugs When

leaded fuel is used, refer to ~severe driving condition~ schedule.

FUEL

3-1. Air cleaner filter element Paved-road Inspect every 20000 km (12500 miles) or 12 months.

Replace every 40000 km (25000 miles) or 36 months.

Dusty condition

Refer to "Severe driving

condition~ schedule.

*3-2. Fuel lines

= I : I = I : I

-

I

*3-3. Fuel tank

- I

#1: For further details, see "Engine oil and filter" in this section.

#2: Perform the engine coolant level check under the daily inspection in the "OPERATING YOUR VEHICLE" section.

If you use the engine coolant other than "SUZUKI LLC: Super (Blue)" for replacement, follow the schedule of "SUZUKI LLC: Stan-

dard (Green)". (Replace every 40000 km (25000 miles) or 36 months.)

6-15

INSPECTION AND MAINTENANCE

Interval: This interval should be judged bylf---------------------a"'-<"~ccfl---c~+--,;;;.-+~

odometer reading or months, whichever1

km (x1000)I

20 I

40

I

60

I

80

I 100 I 120

miles (x1000)I 12.5 I 25

I 37.5 I 50

I 62.5 I 75

comes first.

I

f-----------------------"='-"'-'-=-;?l----'-~+---:a,;-+~

months! 12

24 I 36

I

48

I

60

I 72

EMISSION CONTROL SYSTEM

•4-1. PCV valve

•4-2. Fuel evaporative emission control system

BRAKE

*5-1. Brake discs and pads (front)

Brake drums and shoes (rear)

*5-2. Brake hoses and pipes

5-3. Brake fluid (#3)

*5-4. Brake (Pedal and fluid level)

5-5. Brake lever and cable

CHASSIS AND BODY

*6-1. Clutch fluid (#3)

*6-2. Clutch (Pedal and fluid level)

6-3. Tyres/Wheels

*6-4. Wheel bearings

•6-5. Propeller shafts

*6-6. Suspension system

*6-7. Steering system

*6-8. Manual transmission oil

*6-9. Automatic transmission oil

*6-10. Transfer oil

*6-11. Differential oil

6-12. All latches, hinges and locks

*6-13. Air conditioner filter element

Check, *Replacement

Check, *Adjustment (1st 20000 km only)

Genuine "SUZUKI GEAR OIL 75W"

Other than "SUZUKI GEAR OIL 75W"

Fluid level

*Fluid change

*Fluid hose

Genuine "SUZUKI GEAR OIL 75W"

Other than "SUZUKI GEAR OIL 75W"

Genuine "SUZUKI SUPER GEAR OIL 75W-85 SYNTHETIC"

#3: Clutch fluid is supplied from brake fluid reservoir.

A WARNING

I

-

I

-

I

-

I

-

I

-

- -

-

- - I

I

I I I

I I

- I

-

I

- I

-

I

- R

-

R

I I

I I I

I

-

- -

-

R

- R

I I

I I I

I

I I I

I I

-

I

-

I

- I

-

I

- I

-

I

- I

-

I

Inspect every 40000 km (25000 miles) or 24 months.

= I 7 I = I 7 I = I 7

Replace every 165000 km (99000 miles).

- I - I I I - I - I I

Inspect every 40000 km (25000 miles) or 24 months.

- R - R - R

R

I

R

The shock absorbers are filled with high pressure gas. Never attempt to disassemble them or throw them into a fire. Avoid

storing them near a heater or heating device. When scrapping the absorber, the gas must be released from the absorber

safely. Ask your dealer for assistance.

6-16

INSPECTION AND MAINTENANCE

Interval: This interval should be judged byl-1-----------------------;c"--f'-;~:cfl-....,;,;_:;,-+----;.;;;-+~

odometer reading or months, whichever

1

km (x1000)

140 160 180 I 200 I 220 I

240

miles (x1000) 87.5

100 112.5 125 I 137.5 I

150

comes first. rl---------------------===.cc-:;"'1---",;.;::.-+-',:;;.-+--'

months 84

96 108

120 I

132

I

144

EMISSION CONTROL SYSTEM

*4-1. PCVvalve

*4-2. Fuel evaporative emission control system

BRAKE

*5-1. Brake discs and pads (front)

Brake drums and shoes (rear)

*5-2. Brake hoses and pipes

5-3. Brake fluid (#3)

*5-4. Brake (Pedal and fluid level)

5-5. Brake lever and cable

CHASSIS AND BODY

*6-1. Clutch fluid (#3)

*6-2. Clutch (Pedal and fluid level)

6-3. Tyres/Wheels

*6-4. Wheel bearings

*6-5. Propeller shafts

*6-6. Suspension system

*6-7. Steering system

*6-8. Manual transmission all

*6-9. Automatic transmission oil

*6-10. Transfer oil

*6-11. Differential oil

6-12. All latches, hinges and locks

*6-13. Air conditioner filter element

Check, *Replacement

Check, *Adjustment (1st 20000 km only)

Genuine "SUZUKI GEAR OIL 75W"

Other than "SUZUKI GEAR OIL 75W"

Fluid level

*Fluid change

*Fluid hose

Genuine "SUZUKI GEAR OIL 75W"

Other than "SUZUKI GEAR OIL 75W"

Genuine "SUZUKI SUPER GEAR OIL 75W-85 SYNTHETIC"

#3: Clutch fiuid is supplied from brake fiuid reservoir.

6-17

I

-

I

-

I

-

I

-

I

- -

-

- -

I

I I . I

I I I

-

I -

I

-

I

-

I -

I

-

I

-

R

-

R -

R

I

I I I I

I

- -

-

R -

R

-

R

I I

I I I I

I I I

-

I

-

I

-

I

-

I -

I

-

I

-

I

-

I -

I

-

I

-

I -

I

Inspect every 40000 km (25000 miles) or 24 months.

= I I = I I = I

Replace every 165000 km (99000 miles).

- I - I I I - I - I I

Inspect every 40000 km (25000 miles) or 24 months.

- R - R - R

R

I

R

INSPECTION AND MAINTENANCE -> Periodic maintenance schedule (for EU countries and Israel) for Your Suzuki Jimny SUV Fourth Generation (2018-2026)

Related Topics

Popular Owner Manuals

Latest Owner Manuals