Driving and operating -> AdBlue for Your Vauxhall Insignia 4 Door Second Generation (2018-2022)

Driving and operating  
161  
In the event of misfiring, uneven  
engine running, a reduction in engine  
performance or other unusual  
problems, have the cause of the fault  
rectified by a workshop as soon as  
possible. In an emergency, driving  
can be continued for a short period,  
keeping vehicle speed and engine  
speed low.  
Cleaning process not possible  
If cleaning is not possible for any  
reason, control indicator Z  
illuminates and a warning message  
appears in the Driver Information  
Centre. Engine power may be  
reduced. Seek the assistance of a  
workshop immediately.  
9 Warning  
Avoid contact of your eyes or skin  
with AdBlue.  
In case of eye or skin contact,  
rinse off with water.  
Caution  
Catalytic converter  
AdBlue  
General information  
The selective catalytic reduction  
(BlueInjection) is a method to  
substantially reduce the nitrogen  
oxides in the exhaust emission. This  
is achieved by injecting a Diesel  
Exhaust Fluid (DEF) into the exhaust  
system. The ammonia released by  
the fluid reacts with nitrous gases  
(NOx) from the exhaust and turns it  
Avoid contact of the paintwork with  
AdBlue.  
In case of contact, rinse off with  
water.  
The catalytic converter reduces the  
amount of harmful substances in the  
exhaust gases.  
Caution  
AdBlue freezes at a temperature of  
approx. -11 °C. As the vehicle is  
equipped with an AdBlue pre-heater,  
the emissions reduction at low  
temperatures is ensured. The AdBlue  
pre-heater works automatically.  
Fuel grades other than those listed  
on pages 3 220, 3 284 could  
damage the catalytic converter or  
electronic components.  
Unburnt petrol will overheat and  
damage the catalytic converter.  
Therefore avoid excessive use of  
the starter, running the fuel tank  
dry and starting the engine by  
pushing or towing.  
The typical AdBlue consumption is  
approx. 2 l per 600 miles, but can also  
be higher depending on driving  
into nitrogen and water.  
The designation of this fluid is  
AdBlue®. It is a non-toxic, non-  
flammable, colourless and odourless  
fluid which consists of 32% urea and  
68% water.  
behaviour (e.g. high load or towing).  
AdBlue tank  
The AdBlue tank level can be found in  
the display menu.  
162  
Driving and operating  
Notice  
Level warnings  
High emission warnings  
In case of high AdBlue consumption,  
the Driver Information Centre may  
display this warning without the  
previous warning stages.  
Depending on the calculated range of  
AdBlue, different messages are  
displayed in the Driver Information  
Centre. The messages and the  
restrictions are a legal requirement.  
The first possible warning is AdBlue  
Range: 1500 miles.  
This warning will show up once briefly  
with the calculated range. Driving is  
possible without any restrictions.  
The next warning level is entered with  
a range below 1090 miles. The  
message with the current range will  
always be displayed when ignition is  
switched on and needs to be  
confirmed 3 110. Refill AdBlue before  
entering the next warning level.  
If the exhaust emission rises above a  
certain value, warnings similar to the  
range warnings will be displayed in  
the Driver Information Centre.  
Requests to have the exhaust system  
checked and finally the  
announcement of the prevention of  
an engine restart are displayed.  
These restrictions are a legal  
requirement.  
The last warning level is entered  
when the AdBlue tank is empty.  
Restart of the engine is not possible.  
The following warning messages are  
alternately displayed and cannot be  
dismissed:  
AdBlue Empty Refill Now  
Engine Will Not Restart.  
Consult a workshop for assistance.  
Refilling AdBlue  
Additionally, control indicator Y  
flashes continuously.  
With active prevention of an engine  
start, the following message will be  
displayed:  
Caution  
Only use AdBlue that complies  
with European standards  
DIN 70 070 and ISO 22241-1.  
Do not use additives.  
Do not dilute AdBlue.  
Otherwise the selective catalytic  
reduction system could be  
damaged.  
At an AdBlue range below 560 miles,  
the following warning messages are  
alternately displayed and cannot be  
dismissed:  
Refill AdBlue To Start Vehicle.  
The tank must be refilled completely  
with AdBlue, otherwise restarting of  
the engine is not possible 3 289.  
AdBlue Low Refill Now  
Engine Restart Prevented in  
560 miles.  
Additionally, control indicator Y  
flashes continuously.  
Driving and operating  
163  
Notice  
The vehicle must be parked on a level  
surface.  
The filler neck for AdBlue is located  
behind the fuel filler flap, which is  
located at right rear side of the  
vehicle.  
The fuel filler flap can only be opened  
if the vehicle is unlocked.  
1. Remove key from ignition switch.  
5. Open AdBlue canister.  
Whenever a filling pump with a  
nozzle for passenger cars is not  
available at a filling station, use only  
AdBlue bottles or canisters with a  
sealed refill adapter for refilling, to  
prevent splashback and overspill,  
and in order to ensure that the fumes  
from the tank are captured and do  
not emerge. AdBlue in bottles or  
canisters is available in many filling  
stations and can be purchased e.g.  
at Vauxhall dealers and other retail  
outlets.  
6. Mount one end of the hose on the  
canister and screw the other end  
on the filler neck.  
7. Lift the canister until it is empty, or  
until the flow from the canister has  
stopped. This can take up to  
five minutes.  
8. Place the canister on the ground  
to empty the hose, wait  
15 seconds.  
2. Close all doors to avoid ammonia  
fumes entering the interior of the  
vehicle.  
9. Unscrew the hose from the filler  
neck.  
3. Release the fuel filler flap by  
Since AdBlue has a limited  
durability, check the date of expiry  
before refilling.  
pushing the flap 3 222.  
10. Mount the protective cap and turn  
clockwise until it engages.  
Notice  
Notice  
Dispose of AdBlue canister  
according to environmental  
requirements. To reuse the hose  
flush it with clear water after usage.  
When unscrewing the protective cap  
from the filler neck, ammonia fumes  
may emerge. Do not inhale as the  
fumes have a pungent smell. The  
fumes are not harmful by inhalation.  
The AdBlue tank should be filled  
completely. This must be done if the  
warning message regarding  
prevention of an engine restart is  
already displayed.  
4. Unscrew protective cap from the  
filler neck.